动态采空区非线性氧化升温相似试验研究

doi:10.16265/j.cnki.issn 1003-3033.2020.11.014

中国安全科学学报 ›› 2020, Vol. 30 ›› Issue (11): 95-100.doi: 10.16265/j.cnki.issn 1003-3033.2020.11.014

动态采空区非线性氧化升温相似试验研究

周佩玲¹ 助理研究员, 袁飞^2,3 讲师, 赵鹏霞¹ 助理研究员

1 北京城市系统工程研究中心,北京 100035;
2 北京科技大学冶金与生态工程学院,北京 100083;
3 北京科技大学钢铁冶金新技术国家重点实验室,北京 100083

收稿日期:2020-08-07 修回日期:2020-10-10 出版日期:2020-11-28
作者简介:周佩玲 (1988—),女,甘肃天水人,博士,助理研究员,主要从事公共安全应急科技与管理、煤矿安全、火灾成因理论及预防等方面的研究。E-mail:pellyzhou@163.com。
基金资助:
国家重点研发计划项目(2018YFC0809700)。

Similar experimental study on non-linear oxidation heating up process of coal in dynamic gob areas

ZHOU Peiling¹, YUAN Fei^2,3, ZHAO Pengxia¹

1 Beijing Research Center of Urban System Engineering, Beijing 100035, China;
2 School of Metallurgical and Ecological Engineering, University of Science and Technology Beijing, Beijing 100083, China;
3 State Key Laboratory of Advanced Metallurgy, University of Science and Technology Beijing, Beijing 100083, China

Received:2020-08-07 Revised:2020-10-10 Published:2020-11-28

摘要/Abstract

摘要： 为深入研究采空区遗煤的氧化升温特征,利用容积平均法构建传热传质模型,搭建采空区氧化升温相似试验台,试验研究采空区遗煤氧化的非线性升温过程,并通过现场试验数据验证相似试验的结果。结果表明:采空区温度场中,高温区域主要集中在进风侧,并且随着工作面动态推进,不断向前迁移,采空区温度随时间呈指数增长;工作面推进速度是影响采空区温度升高的重要因素,推进速度越快,采空区升温速率越小,其中,工作面推进速度与采空区最高温度之间呈负指数减小的关系;同时,随着工作面推进速度的加快,采空区高温点位置距工作面距离不断增加;采空区特征点升温曲线拟合结果显示,现场试验值与相似模拟值基本吻合,证明了相似试验的合理性。

关键词: 动态采空区, 氧化升温, 相似试验, 遗煤自燃, 工作面推进速度

Abstract: In order to explore deeper into oxidation heating characteristics of residual coal in gob areas, a similar experimental platform was built based on heat and mass transfer model which was established by volume average method. Nonlinear heating up process of such residual coal was studied and similar experiment results were verified by field test data. The results show that high temperature area mainly concentrates on air inlet side, and it will move forward along with advancing of working face while temperature in gob areas increase exponentially over time. Advancing speed of working face is a main factor that influences oxidation heating up process, the faster it is, the smaller heating rate of gob will be, and there is a negative exponential reduction relationship between it and maximum temperature in gob. Meanwhile, along with its increase, depth of maximum temperature point increase gradually. According to fitting curves of characteristic points' heating up in gob, it is also found that experimental results are basically consistent with that of field experiment, which proves rationality of similar experiment.

Key words: dynamic gob areas, oxidation heating up, similar experiment, spontaneous combustion of coal, working face advancing speed

周佩玲助理, 袁飞, 赵鹏霞. 动态采空区非线性氧化升温相似试验研究[J]. 中国安全科学学报, 2020, 30(11): 95-100.

ZHOU Peiling, YUAN Fei, ZHAO Pengxia. Similar experimental study on non-linear oxidation heating up process of coal in dynamic gob areas[J]. China Safety Science Journal, 2020, 30(11): 95-100.

参考文献

[1] 谢军, 薛生. 综放采空区空间自燃三带划分指标及方法研究[J]. 煤炭科学技术, 2011, 39(1): 65-68.
XIE Jun, XUE Sheng. Study on division index and method of three spontaneous combustion zones in goaf of fully mechanized top coal caving mining face [J]. Coal Science and Technology, 2011, 39(1): 65-68.
[2] 秦波涛, 王德明, 李增华, 等. 以活化能的观点研究煤炭自燃机理[J]. 中国安全科学学报, 2005, 15(1): 14-16.
QIN Botao, WANG Deming, LI Zenghua, et al. Study on the mechanism of coal spontaneous combustion with activity view [J]. China Safety Science Journal, 2005, 15(1): 14-16.
[3] ZHAI Xiaowei, DENG Jun, WEN Hu, et al. Research of the air leakage law and control techniques of the spontaneous combustion dangerous zone of re-mining coal body[J]. Procedia Engineering, 2011, 26: 472-479.
[4] 董子文, 齐庆杰, 韩光, 等. 采空区氧化带与发火期动态演化规律模拟研究[J]. 中国安全科学学报, 2018, 28(7): 45-50.
DONG Ziwen, QI Qingjie, HAN Guang, et al. Numerical simulation study on dynamical evolution rule of spontaneous combustion oxidation zone and period [J]. China Safety Science Journal, 2018, 28(7): 45-50.
[5] 李树刚, 赵鹏翔, 林海飞, 等. 煤岩瓦斯“固-气”耦合物理模拟相似材料特性实验研究[J]. 煤炭学报, 2015, 40(1): 80-86.
LI Shugang, ZHAO Pengxiang, LIN Haifei, et al. Study on character of physical simulation similar material of coal-rock and gas solid-gas coupling [J]. Journal of China Coal Society, 2015, 40(1): 80-86.
[6] CHENG Weimin, SUN Lulu, WANG Gang, et al. Experimental re.search on coal seam similar material ratio and its application [J]. International Journal of Mining Science and Technology, 2016, 26: 913-918.
[7] LOMIZE G M. Flow in fracture rocks[M]. Moscow: Gesenergoizdat, 1951: 60-70.
[8] 林韵梅,实验岩石力学模拟研究[M]. 北京:煤炭工业出版社, 1984: 90-101.
[9] 叶振兴. 煤的低温氧化实验及对模拟试验数值模拟研究[D]. 淮南: 安徽理工大学, 2005.
YE Zhenxing. Low-temperature oxidation experiment of coal and numerical simulation study on the simulation test [D]. Huainan: Anhui University of Science and Technology, 2005.
[10] 周春山. 煤自然实验过程中温度场的数值模拟研究[D]. 太原: 太原理工大学, 2007.
ZHOU Chunshan. Numerical simulation of the temperature field in the experiment of spontaneous coal combustion [D]. Taiyuan: Taiyuan University of Technology, 2007.
[11] 丁厚成. U+L型通风采空区瓦斯运移数值模拟与实验研究[J]. 自然灾害学报, 2012, 21(6): 192-198.
DING Houcheng. Numerical simulation and experiment research on gas migration in gob areas under U+L type ventilatoin [J]. Journal of Natural Disasters, 2012, 21(6): 192-198.
[12] 姜华. 采空区气体渗流相似模拟实验平台研发及应用[D]. 西安: 西安科技大学, 2013.
JIANG Hua. The development and application of experimental platform for similar simulation experiment of gob gas seepage [D]. Xi'an: Xi'an University of Science and Technology, 2013.
[13] 王宏山. 采空区自然发火位置预测模型的相似模拟研究[D]. 阜新: 辽宁工程技术大学, 2008.
WANG Hongshan. Study on similar simulation experiment of the prediction model of locations of spontaneous combustion in gob areas [D]. Fuxin: Liaoning Technical University, 2008.
[14] 王树刚, 迟子豪, 张腾飞, 等. U型通风采场的温度场相似实验模型[J]. 中国矿业大学学报, 2012, 41(1): 31-36.
WANG Shugang, CHI Zihao, ZHANG Tengfei, et al. A scaled test model for predicting the temperature field in a coal mine stope with a U-shaped ventilation system[J]. Journal of China University of Mining & Technology, 2012, 41(1): 31-36.
[15] 张春, 题正义, 李宗翔. 采空区孔隙率的空间立体分析研究[J]. 长江科学院院报, 2012, 29(6): 52-57.
ZHANG Chun, TI Zhengyi, LI Zongxiang. Spatial stereo analysis of porosity in goaf [J]. Journal of Yangtze River Scientific Research Institute, 2012, 29(6): 52-57.

动态采空区非线性氧化升温相似试验研究

Similar experimental study on non-linear oxidation heating up process of coal in dynamic gob areas

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 6

编辑推荐

Metrics

本文评价

[1]	张晓明, 刘筱颖, 董伟, 张河猛, 王永军, 佐佐木久郎. 海州露天矿采空区地表CO₂通量的试验研究[J]. 中国安全科学学报, 2022, 32(2): 66-73.
[2]	周亮, 戴广龙, 秦汝祥. 高瓦斯易自燃煤层采空区遗煤自燃影响因素研究[J]. 中国安全科学学报, 2018, 28(2): 122-127.
[3]	张春, 李集明. 利用岩粉防治遗煤自燃可行性研究[J]. 中国安全科学学报, 2017, 27(4): 60-65.
[4]	黄戈, 王继仁, 邓存宝, 郝朝瑜, 王鑫阳. 电厂烟道气预防遗煤自燃的合理含氧量模拟研究[J]. 中国安全科学学报, 2017, 27(3): 42-47.
[5]	张春，题正义，李宗翔. 综放采空区遗煤自燃的三维数值模拟研究[J]. 中国安全科学学报, 2013, 23(5): 15-.
[6]	王永强，张继春. 基于相似试验的尾矿库溃坝泥石流预测分析[J]. 中国安全科学学报, 2012, 22(12): 70-.