风幕封闭的综掘面硫化氢治理技术研究与应用

doi:10.16265/j.cnki.issn1003-3033.2020.01.012

中国安全科学学报 ›› 2020, Vol. 30 ›› Issue (1): 73-80.doi: 10.16265/j.cnki.issn1003-3033.2020.01.012

风幕封闭的综掘面硫化氢治理技术研究与应用

汪伟^1,2, 贾宝山^1,2 教授, 祁云^1,2

1.辽宁工程技术大学安全科学与工程学院,辽宁阜新 123000;
2.辽宁工程技术大学矿山热动力灾害与防治教育部重点实验室,辽宁葫芦岛 125100

收稿日期:2019-10-12 修回日期:2019-12-22 出版日期:2020-01-28 发布日期:2021-01-22
作者简介:汪伟 (1991—),男,河北玉田人,博士研究生,主要研究方向为安全技术及工程E-mail:303109626@qq.com。
基金资助:
国家重点研发计划重点专项(2018YFC0807900)。

Research and application of hydrogen sulfide control technology with enclosed air curtain in fully-mechanized excavation face

WANG Wei^1,2, JIA Baoshan^1,2, QI Yun^1,2

1. College of Safety Science and Engineering, Liaoning Technical University, Fuxin Liaoning 123000, China;
2. Key Laboratory of Mine Thermodynamic Disasters and Control of Ministry of Education, Liaoning Technical University, Huludao Liaoning 125100, China

Received:2019-10-12 Revised:2019-12-22 Online:2020-01-28 Published:2021-01-22

摘要/Abstract

摘要： 为解决综掘面掘进过程中硫化氢涌出影响矿井安全生产的问题,现场测试分析晋牛矿8116综掘面硫化氢的分布特征,提出利用风幕风机封闭综掘断面,防止硫化氢外溢的治理方案;依据势流叠加原理和流体力学理论,建立空间受限条件下风幕风机流场的数学模型;为验证该模型的正确性,在模拟巷道进行风幕射流速度衰减试验。结果表明:风幕风速随着射流距离的增加不断衰减,且呈现先急后缓的变化趋势,数学模型所计算出的理论风速与实测风速基本一致;径向射流风幕需要封闭的空间断面内,实测风速都在2.7 m/s以上,能有效抑制硫化氢向外逸散。通过井下工程应用,该装置可使掘进机司机处的硫化氢体积分数由43.5×10^-6降至3.2×10^-6,治理效果显著。

关键词: 综掘工作面, 风幕风机, 煤矿硫化氢, 环形射流, 平行平面流

Abstract: In order to avoid influence caused by hydrogen sulfide emission on production safety during mining process of fully-mechanized excavation faces, a new technical plan with wind-curtain ventilator to seal these faces was put forward based on site measurement and analysis of hydrogen sulfide distribution law of No.8116 fully-mechanized excavation face in Jinniu Mine, aiming at preventing its overflow. Secondly, a mathematical model of wind-curtain dust-catching ventilator in confined space was established according to potential superposition principle and fluid mechanics theory. Finally, an air curtain jet velocity attenuation experiment was conducted to verify its rationality. The results show that wind curtain velocity will attenuate abruptly in early stage and then slowly later as jet distance grows, and theoretical wind velocity calculated through this model is basically consistent with measured one. In space sections where air curtain jet needs to be sealed, measured wind speed is all above 2.7 m/s, which helps prevent hydrogen sulfide from leaking. Through field installation and application, concentration of hydrogen sulfide at driver's position can be reduced from 72.5×10^-6 to 6.3×10^-6, thus achieving good control effect of hydrogen sulfide.

Key words: fully-mechanized excavation face, wind-curtain ventilator, mine hydrogen sulfide, circular jet, parallel plane flow

中图分类号:

X962

汪伟, 贾宝山, 祁云. 风幕封闭的综掘面硫化氢治理技术研究与应用[J]. 中国安全科学学报, 2020, 30(1): 73-80.

WANG Wei, JIA Baoshan, QI Yun. Research and application of hydrogen sulfide control technology with enclosed air curtain in fully-mechanized excavation face[J]. China Safety Science Journal, 2020, 30(1): 73-80.

参考文献

[1] 刘明举,李国旗,HANI Mitri,等.煤矿硫化氢气体成因类型探讨[J].煤炭学报,2011,36(6): 978-983.
LIU Mingju, LI Guoqi, HANI Mitri, et al.Genesis modes discussion of H₂S gas in coal mines [J]. Journal of China Coal Society,2011,36(6):978-983.
[2] LIU Mingju, DENG Qigen, ZHAO Fajun, et al. Origin of hydrogen sulfide in coal seams in China[J].Safety Science, 2012,50 (4): 668-673.
[3] 张广太.煤矿硫化氢赋存机理及治理研究[D].太原:太原理工大学,2007.
ZHANG Guangtai. Study on the occurrence mechanism and treatment of hydrogen sulfide in coal mine[D]. Taiyuan: Taiyuan University of Technology,2007.
[4] 姚亚虎,黄中峰,刘军.急倾斜特厚煤层硫化氢涌出规律及控制技术研究[J].煤炭工程,2017,49(1): 56-59.
YAO Yahu, HUANG Zhongfeng, LIU Jun. Research on control technology and emission law of hydrogen sulfide in steeply dipping and extra-thick coal seam[J].Coal Engineering,2017,49(1): 56-59.
[5] 傅雪海,王文峰,岳建华,等.枣庄八一矿瓦斯中H₂S气体异常成因分析[J].煤炭学报,2006,31(2): 206-210.
FU Xuehai, WANG Wenfeng, YUE Jianhua, et al. Genesis analyses of H₂S gas abnormity in gas of Bayi coal mine in Zaozhuang[J]. Journal of China Coal Society,2006,31(2): 206-210.
[6] 刘奎.综放工作面硫化氢分布规律及治理技术研究[J].矿业安全与环保,2016,43(2): 13-18.
LIU Kui.Study on distribution law and control technology of H₂S gas in fully mechanized caving face[J]. Mining Safety and Environmental Protection,2016,43(2): 13-18.
[7] 韩德馨.中国煤岩学[M].徐州:中国矿业大学出版社,1996: 370-385.
[8] 邓奇根,王颖南,吴喜发,等.煤矿硫化氢防治技术研究进展[J].科技导报,2018,36(2): 81-87.
DENG Qigen,WANG Yingnan,WU Xifa, et al. Research progress of prevention and control technology of hydrogen sulfide in coal mines[J].Science & Technology Review,2018,36(2): 81-87.
[9] 苗永春,付玉凯.煤矿硫化氢赋存机理及综合治理方法研究[J].煤炭技术,2015,34(3): 227-230.
MIAO Yongchun, FU Yukai.Study on hydrogen sulphide forming mechanism and comprehensive management in mine[J].Coal Technology,2015,34(3): 227-230.
[10] 林海,韦威,王亚楠,等.煤矿井下硫化氢气体的快速控制实验研究[J].煤炭学报,2012,37(12): 2 065-2 069.
LIN Hai, WEI Wei, WANG Ya'nan, et al. Study on the rapid removal of H₂S in underground coal mines[J].Journal of China Coal Society,2012,37(12): 2 065-2 069.
[11] 王岩,梁冰,袁欣鹏.深孔控制预裂爆破在高硫化氢矿井瓦斯强化抽采中的应用[J].重庆大学学报,2013,36 (5): 101-104.
WANG Yan, LIANG Bing,YUAN Xinpeng.The application of deep hole per-split blasting to gas improvedextraction in high hydrogen sulphide mine[J].Journal of Chongqing University,2013,36(5): 101-104.
[12] 袁欣鹏,梁冰,孙维吉,等.煤层注碱治理矿井硫化氢涌出危害研究[J].中国安全科学学报,2015,25(5): 114-119.
YUAN Xinpeng, LIANG Bing, SUN Weiji, et al. Research on control of mine hydrogen sulfide emission by injecting sodium bicarbonate solution into coal seams[J].China Safety Science Journal,2015,25(5): 114-119.
[13] 刘奎.综掘工作面硫化氢分布规律及其泡沫治理技术[J].煤炭科学技术,2017,45(2): 71-75.
LIU Kui. Hydrogen sulfide distribution law and foam control technology of fully-mechanized gateway driving face[J].Coal Science and Technology,2017,45(2): 71-75.
[14] 梁冰,袁欣鹏,孙维吉,等.煤层注碱治理硫化氢数值模拟与应用[J].中国矿业大学学报,2017,46(2): 244-249.
LIANG Bing, YUAN Xinpeng, SUN Weiji,et al. Numerical simulation of lye injection into coal seams for governance of H₂S and its field applications[J]. Journal of China University of Mining & Technology,2017, 46(2): 244-249.
[15] 段文义,郭仁东,李亚峰.流体力学[M].沈阳:东北大学出版社,2001: 151-194.
[16] 沈连山.数值分析及其应用[M].沈阳:东北大学出版社,1996: 50-53.
[17] 王新月.气体动力学基础[M].西安:西北工业大学出版社,2006: 121-139.

风幕封闭的综掘面硫化氢治理技术研究与应用

Research and application of hydrogen sulfide control technology with enclosed air curtain in fully-mechanized excavation face

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	张艳娇, 徐向宇, 姜婉, 姚龙龙. 综掘面尘源位置对负压抽风口位置的影响[J]. 中国安全科学学报, 2021, 31(4): 147-155.
[2]	黄宜生, 胡胜勇, 邵和, 廖奇, 高扬, 胡斐. 综掘工作面分级除尘系统及其应用[J]. 中国安全科学学报, 2019, 29(9): 150-154.
[3]	张建卓，祝天姿，高猛，李康康. 综掘面风幕集尘除尘系统的参数优化与数值模拟[J]. 中国安全科学学报, 2011, 21(4): 128-.
[4]	蔡成功. 综掘工作面卸压槽防突措施试验研究[J]. 中国安全科学学报, 2004, 14(4): 83-.