含水率对防护织物热防护性能的影响

doi:10.16265/j.cnki.issn1003-3033.2018.07.024

中国安全科学学报 ›› 2018, Vol. 28 ›› Issue (7): 148-152.doi: 10.16265/j.cnki.issn1003-3033.2018.07.024

含水率对防护织物热防护性能的影响

翟胜男^1,2, 陈太球³, 蒋春燕³, 傅佳佳^1,2 副教授, 王鸿博^**1,2 教授

1 江南大学江苏省功能纺织品工程技术研究中心,江苏无锡 214122;
2 江南大学生态纺织教育部重点试验室, 江苏无锡 214122;
3 圣华盾防护科技股份有限公司,江苏无锡 214413

收稿日期:2018-04-10 修回日期:2018-05-28 出版日期:2018-07-28 发布日期:2020-11-25
通讯作者: **王鸿博(1964—),男,江苏无锡人,教授,主要从事功能纺织品方面的研究。E-mail:wxwanghb@163.com。
作者简介:翟胜男(1993—),女,山东淄博人,硕士研究生,研究方向为功能纺织品和热防护纺织品。E-mail:447691696@qq.com。
基金资助:
“十三五”国家重大研发项目(2016YFC0802806);江苏省产学研前瞻性研究项目(BY2016221-23);中央高校基本科研业务费专项资金资助(JUSRP51622A)。

Effect of moisture of firefighter fabric onits thermal protective performance

ZHAI Shengnan^1,2, CHEN Taiqiu³, JIANG Chunyan³, FU Jiajia^1,2, WANG Hongbo^1,2

1 Jiangsu Functional Textile Engineering Technology Research Center,Jiangnan University,Wuxi Jiangsu 214122,China;
2 Key Laboratory of Eco-Textile,Jiangnan University,Wuxi Jiangsu 214122,China;
3 Shenghuadun Protection Co.,Ltd.,Wuxi Jiangsu 214122,China

Received:2018-04-10 Revised:2018-05-28 Online:2018-07-28 Published:2020-11-25

摘要/Abstract

摘要： 为了解热防护织物吸湿状态下的防护性能,以提高织物的安全防护能力,首先,选取热防护织物组成多层组合S-1和S-2,利用热防护性能测试仪,分别测试织物组合S-1和S-2在外层织物不同含水率情况下的热防护性能(TPP)值及二级烧伤时间;然后,建立线性回归方程,描述在 4种含水率下织物TPP的变化情况,分析外层织物的含水率对热防护服多层织物组合TPP的影响。结果表明:对于所有织物组合,二度烧伤时间和TPP值都随外层织物含水率的增加而明显增加;当外层织物的含水率增加到30%左右时,外层织物的含水率直接影响消防服整体的TPP,含水率越高,消防服的TPP越好。

关键词: 热防护织物, 含水率, 热防护性能(TPP), 二级烧伤时间, 回归方程

Abstract: In order to determine the protective properties of thermal protective fabrics under humid conditions and improve the ability of fabric,firsly,the thermal protection fabrics were selected to form multi-layer combinations S-1 and S-2,the TPP and second-degree burn time of multi-layer fabrics combinations S-1 and S-2 were determined as a function of moisture of outer layers by using thermal protection performance test instruments.Then,a linear regression equation was established,and the changes in fabric thermal protection performance at four water cut rates were described.The effect of moisture of outer layer fabric on thermal protection performance of thermal protective clothing multilayer fabric was analyzed.The results show that for all the fabric combinations,there is appositive correction between the TPP or the second degree burn time and moisture of outer layers,that when the moisture of the outer fabric increases to about 30%,the moisture of the outer fabric directly affects the TPP of the whole fire fighting suit,and that the higher the moisture is,the better the TPP will be.

Key words: heat protection fabric, moisture content, thermal protection performance(TPP), second degree burn time, regression equation

中图分类号:

X968
X57

翟胜男, 陈太球, 蒋春燕, 傅佳佳, 王鸿博. 含水率对防护织物热防护性能的影响[J]. 中国安全科学学报, 2018, 28(7): 148-152.

ZHAI Shengnan, CHEN Taiqiu, JIANG Chunyan, FU Jiajia, WANG Hongbo. Effect of moisture of firefighter fabric onits thermal protective performance[J]. China Safety Science Journal, 2018, 28(7): 148-152.

参考文献

[1] 朱方龙,张渭源.基于人体皮肤热模型的热防护服评价方法研究[J].中国安全科学学报,2007,17(11):134-140.
ZHU Fanglong,ZHANG Weiyuan.Study on estimstion of thermal protective clothing based on human skin heat transfer model[J].China Safety Sciences Journal,2007,17(11):134-140.
[2] 黄冬梅,何松.空气层位置对消防战斗服隔热性能的影响[J].纺织学报,2015,36(10):113－119.
HUNG Dongmei,HE Song.Influence of air gap position on the heat insulation performance of firefighters' protective clothing[J].Journal of Textile,2015,36(10):113-119.
[3] BARKER R L,GRIMES R V,HAMOUDA H,et al.Effects of moisture on the thermal protective performance of firefighter protective clothing in low-level radiant heat exposures[J].Textile Research Journal,2006,76(1):27-31.
[4] CHEN Meng,ZHU Fanglong,FENG Qianqian,et.al.Experimental study on moisture transfer through firefighters' protective fabrics in radiant heat exposures[J].Thermal Science,2017,21(4):1 665-1 671.
[5] SONG Guowen,STEPHEN P,ROHIT S,et al.Thermal protective performance of protective clothing used for low radiant heat protection[J].Textile Research Journal,2011,81(3):311-323.
[6] LEE Y M,BARKER R L.Effect of moisture on the thermal protective performance of heat resistant fabrics[J].Journal of Fire Sciences,1986,4(5):315-331.
[7] LI Jun,LU Yehu,LI Xiaohui.Effect of relative humidity coupled with air gap on heat transfer of flame-resistant fabrics exposed to flash fires[J].Textile Research Journal,2012,82(82):1 235-1 243.
[8] KEISER C,BECKER C,ROSSI R M.Moisture transport and absorption in multilayer protective clothing fabrics[J].Textile Research Journal,2008,78(7):604-613.
[9] CHEN Naiyun.Transient heat and moisture transfer to skin through thermally-irradiated cloth[D].Cabridge Massachusetts Institute of Technology,1959.
[10] MORSE A L.Analysis of the thermal response of protective fabrics[R].Technical Report AFML-TR-73-17,Air Force Materials Laboratory,NTIS-AD-759 525,1973.
[11] 李红燕.单层织物湿态热防护性能测试与分析[J].纺织学报,2009,30(12):95-98.
LI Hongyan.Test and analysis of wet thermal protective performance of single layer fabric[J].Journal of Textile,2009,30 (12):95-98.
[12] 何华玲,于志财,张健飞,等.含水率对消防服用多层织物系统热蓄积的影响[J].纺织学报,2017,38(8):108-113.
HE Hualing,YU Zhicai,ZHANG Jianfei,et al.Influence of moisture content on heat storage performance of multilayer fabric assemblies for firefighters[J].Journal of Textile,2017,38(8):108-113.
[13] HE Hualing,YU Zhicai,SONG Guowen.The effect of moisture and air gap on the thermal protective performance of fabric assemblies used by wildland firefighters[J].Journal of the Textile Institute Proceedings and Abstracts,2015,107(8):1 030-1 036.
[14] GA10—2014,消防员灭火防护服[S].
GA10-2014,Standard of firefighter fire protection suit[S].

含水率对防护织物热防护性能的影响

Effect of moisture of firefighter fabric onits thermal protective performance

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 11

编辑推荐

Metrics

本文评价

[1]	任永婕, 魏建平, 温志辉, 张俊昭, 姚帅. 煤岩自振频率的影响因素试验研究^*[J]. 中国安全科学学报, 2021, 31(8): 104-111.
[2]	易富, 于犇, 于汇泽, 杜常博, 金洪松. 三向格栅与细粒尾矿界面特性拉拔试验研究[J]. 中国安全科学学报, 2021, 31(1): 67-74.
[3]	刘艳, 刘永, 徐正华, 洪昌寿, 章求才, 袁劲帆. 长期高温下铀尾矿库覆土层控氡性能研究[J]. 中国安全科学学报, 2020, 30(3): 171-177.
[4]	周西华, 童谣, 宋东平, 白刚, 李昂. 基于响应曲面法的松散煤体导热系数测试与分析[J]. 中国安全科学学报, 2018, 28(10): 105-110.
[5]	康向涛, 刘勇, 江成玉, 宋真龙, 高林. 含水率对预制裂纹煤样能耗与破坏模式的影响[J]. 中国安全科学学报, 2017, 27(7): 94-98.
[6]	林雪松, 陈殿强, 王来贵. 非饱和尾矿砂抗剪强度参数分布与安全影响[J]. 中国安全科学学报, 2017, 27(4): 116-121.
[7]	岳基伟, 王兆丰教授, 陈金生讲师, 李皓伟. 用水敏指示剂快速测定重塑煤体渗吸高度的研究[J]. 中国安全科学学报, 2017, 27(11): 126-131.
[8]	李孜军，徐志国，邓艳星. 氧化增重法测试硫化矿石低温氧化性参数优化[J]. 中国安全科学学报, 2012, 22(6): 54-.
[9]	梁瑞，郭洪燕，郭晓璐. 安全投入模型的研究[J]. 中国安全科学学报, 2011, 21(1): 32-.
[10]	路长，余明高，林棉金，陈亮，贾海林. 水分影响下阴燃传播及气相反应发生的研究[J]. 中国安全科学学报, 2008, 18(5): 91-.
[11]	朱方龙，张渭源. 基于人体皮肤热模型的热防护服评价方法研究[J]. 中国安全科学学报, 2007, 17(11): 134-.