浸水褐煤的自燃特性及红外分析

doi:10.16265/j.cnki.issn1003-3033.2018.08.018

中国安全科学学报 ›› 2018, Vol. 28 ›› Issue (8): 105-110.doi: 10.16265/j.cnki.issn1003-3033.2018.08.018

浸水褐煤的自燃特性及红外分析

邓存宝^1,2 教授, 乔玲¹, 王雪峰¹ 副教授, 戴凤威^1,2, 张勋^3,4

1 辽宁工程技术大学安全科学与工程学院,辽宁阜新123000;
2 辽宁工程技术大学安全工程技术研究院,辽宁阜新123000;
3 辽宁工程技术大学矿业学院,辽宁阜新 123000;
4 山西焦煤集团有限责任公司,山西太原 030000

收稿日期:2018-05-06 修回日期:2018-07-12 出版日期:2018-08-28 发布日期:2020-11-25
作者简介:邓存宝(1964—),男,山西大同人,教授,博士生导师,主要从事矿井瓦斯灾害防治和防灭火方面的研究。E-mail:dengcunbao323@163.com。
基金资助:
国家自然科学基金资助(51604144);辽宁省自然科学基金资助(20170540430)。

Spontaneous combustion characteristics and infrared analysis of soaked lignite

DENG Cunbao^1,2, QIAO Ling ¹, WANG Xuefeng¹, DAI Fengwei^1,2, ZHANG Xun^3,4

1 College of Safety Science and Engineering,Liaoning Technical University,Fuxin Liaoning 123000,China;
2 Safety Engineering Technology Research Institute,Liaoning Technical University,Fuxin Liaoning 123000,China;
3 College of Mining Engineering,Liaoning Technical University,Fuxin Liaoning 123000,China;
4 Shanxi Coking Coal Group Co.Ltd.,Taiyuan Shanxi 030000,China

Received:2018-05-06 Revised:2018-07-12 Online:2018-08-28 Published:2020-11-25

摘要/Abstract

摘要： 为防治采空区遗煤浸水后引发的自燃火灾,制备褐煤原煤及浸水煤煤样,进行程序升温试验,测试煤样的傅里叶变换红外(FT-IR)光谱,并通过分区拟合分析浸水对煤分子结构的影响。结果表明:浸水煤的失水结束点温度、着火温度和最大失重速率点温度较原煤均有不同程度的提前,着火活化能降低了11.2%,说明浸水煤更容易发生自燃;浸水后煤中烷基醚、芳基醚、亚甲基以及自缔合羟基氢键等基团含量升高,导致煤体活性增强。

关键词: 浸水, 褐煤, 傅里叶变换红外(FT-IR)光谱, 自燃特性, 煤结构

Abstract: In order to prevent self-igniting fire caused by soaking of residual coal in goaf,lignite samples and soaked coal samples were prepared,and temperature programmed experiments were carried out to study the change of the spontaneous combustion characteristics.FT-IR spectra of the coal samples were obtained,and the influences of soaking on the functional groups of coal were quantitatively analyzed.The results show that the temperature of the end point of water evaporation,the ignition temperature and the temperature corresponding to the maximum weight loss rate of the soaked coal sample are advanced in varying degree,and the ignition activation energy is reduced by 11.2%,indicating that the soaked lignite is more prone to spontaneous combustion,and the contents of alkyl ether,aryl ether,methylene and self associative hydroxyl hydrogen bond in the coal are increased,and the oxidation activity of coal are enhanced after soaking.

Key words: soaking, lignite, Fourier transform infrared (FT-IR) spectrum, spontaneous combustion characteristics, coal structure

中图分类号:

X936

邓存宝, 乔玲, 王雪峰, 戴凤威, 张勋. 浸水褐煤的自燃特性及红外分析[J]. 中国安全科学学报, 2018, 28(8): 105-110.

DENG Cunbao, QIAO Ling, WANG Xuefeng, DAI Fengwei, ZHANG Xun. Spontaneous combustion characteristics and infrared analysis of soaked lignite[J]. China Safety Science Journal, 2018, 28(8): 105-110.

参考文献

[1] 王德明,矿井火灾学[M].北京:中国矿业大学出版社,2008:53-56.
[2] HODGES D T,TUCKER J R,HARTWICK T S.Basic physical mechanisms determining performance of the CH3F laser[J].Infrared Physics,1976,16(1):175-182.
[3] PHONE J D N,HEIN K A A,STRACHER G B,et al.The spontaneous combustion of coal and its by-products in the witbank and sasolburg coalfields of South Africa[J].International Journal of Coal Geology,2007,72(2):124-140.
[4] HE Qilin,DAI Guanglong,WANG Deming.Critical value of CO of forecasting coal spontaneous combustion[J].International Journal of Mining Science and Technology,2003,13(2):121-125.
[5] 梁晓瑜,王德明.水分对煤炭自燃的影响[J].辽宁工程技术大学学报:自然科学版,2003,22(4):472-474.
LIANG Xiaoyu,WANG Deming.Effects of moisture on spontaneous combustion of coal[J].Journal of Liaoning Technical University:Natural Sciences Edition,2003,22(4):472-474.
[6] 何启林,王德明.煤水分含量对煤吸氧量与放热量影响的测定[J].中国矿业大学学报,2005,34(3):358-362.
HE Qilin,WANG Deming.Influence of moisture on absorbed oxygen and released heat of coal[J].Journal of China University of Mining and Technology,2005,34(3):358-362.
[7] 邓存宝,戴凤威,邓汉忠,等.水溶剂效应对煤氧化特性的影响[J].中国安全生产科学技术,2016,12(3):88-93.
DENG Cunbao,DAI Fengwei,DENG Hanzhong,et al.Influence of water solvent effect on oxidation characteristics of coal[J].Journal of Safety Science and Technology,2016,12(3):88-93.
[8] 邓军,张扬,李成会,等.水浸煤体自燃极限参数和氧化动力学的研究[J].煤炭技术,2016,35(3):152-154.
DENG Jun,ZHANG Yang,LI Chenghui,et al.Research of limit parameters and oxidation kinetics of water-logging coal self-ignition[J].Coal Technology,2016,35(3):152-154.
[9] 文虎,王栋,赵彦辉,等.水浸煤体自燃特性实验研究[J].煤炭技术,2015,34(1):261-263.
WEN Hu,WANG Dong,ZHAO Yanhui,et al.Experimental study on coal spontaneous combustion characteristics of soaked[J].Coal Technology,2015,34(1):261-263.
[10] 唐一博,李云飞,薛生,等.长期水浸对不同烟煤自燃参数与微观特性影响的实验研究[J].煤炭学报,2017,42(10):2 642-2 648.
TANG Yibo,LI Yunfei,XUE Sheng,et al.Experimental investigation of long-term water immersion effect on spontaneous combustion parameters and microscopic characteristics of bituminous[J].Journal of China Coal Society,2017,42(10):2 642-2 648.
[11] 胡荣祖,高胜利,赵凤起,等.热分析动力学[M].北京:科学出版社,2008:148-149.
[12] 邓存宝.煤的自燃机理及自燃危险性指数研究[D].阜新:辽宁工程技术大学,2006.
DENG Cunbao.Study on coal spontaneous combustion mechanisms and the spontaneous combustion danger index[D].Fuxin:Liaoning Technical University,2006.
[13] 梁虎珍,王传格,曾凡桂,等.应用红外光谱研究脱灰对伊敏褐煤结构的影响[J].燃料化学学报,2014,42(2):129-137.
LIANG Huzhen,WANG Chuange,ZENG Fangui,et al.Effect of demineralization lignite structure from Yimin coalfield by FT-IR investigation[J].Journal of Fuel Chemistry and Technology,2014,42(2):129-137.
[14] 李祥,秦志宏,卜良辉,等.炼焦煤的官能团结构分析及其黏结性产生机理[J].燃料化学学报,2016,44(4):385-393.
LI Xiang,QIN Zhihong,BU Lianghui,et al.Structural analysis of functional group and mechanism investigationof caking property of coking coal[J].Journal of Fuel Chemistry and Technology,2016,44(4):385-393.
[15] 杨永良,李增华,尹文宣,等.易自燃煤漫反射红外光谱特征[J].煤炭学报,2007,32(7):729-733.
YANG Yongliang,LI Zenghua,YIN Wenxuan,et al.Infrared diffuse reflectance spectral signature of spontaneous combustion coal[J].Journal of China Coal Society,2007,32(7):729-733.
[16] 褚廷湘,杨胜强,孙燕,等.煤的低温氧化实验研究及红外光谱分析[J].中国安全科学学报,2008,18(1):171-176.
CHU Tingxiang,YANG Shengqiang,SUN Yan,et al.Experimental studyon low temperature oxidization of coal and its infrared spectrum analysis[J].China Safety Science Journal,2008,18(1):171-176.

浸水褐煤的自燃特性及红外分析

Spontaneous combustion characteristics and infrared analysis of soaked lignite

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 6

编辑推荐

Metrics

本文评价

[1]	翟小伟, 葛, 晖, 王, 凯, 吴世博, 王庭焱. 水浸干燥作用对煤自燃特性及预测指标影响研究[J]. 中国安全科学学报, 2018, 28(5): 68-73.
[2]	张晓明, 吴琦, 张河猛, 王永军, 佐佐木久郎. 粒径对褐煤自燃阶段临界温度影响的试验研究[J]. 中国安全科学学报, 2018, 28(4): 36-41.
[3]	王东, 姜聚宇, 韩新平, 南存全, 贺希格图. 褐煤露天矿端帮开采边坡支撑煤柱稳定性研究[J]. 中国安全科学学报, 2017, 27(12): 62-67.
[4]	邓军，赵婧昱，张嬿妮，吴慷，张丹丹，赵萌烨. 陕西侏罗纪煤二次氧化自燃特性试验研究[J]. 中国安全科学学报, 2014, 24(1): 34-.
[5]	郝朝瑜，王鑫阳，赵庆彪，王继仁. 低变质程度煤自燃特性的改进着火活化能方法研究[J]. 中国安全科学学报, 2013, 23(10): 27-.
[6]	高兴生，纪玉龙，辛海会，康延雷. 准东二矿井煤自燃特性及其红外分析[J]. 中国安全科学学报, 2012, 22(10): 101-.