褐煤露天矿端帮开采边坡支撑煤柱稳定性研究

doi:10.16265/j.cnki.issn1003-3033.2017.12.011

中国安全科学学报 ›› 2017, Vol. 27 ›› Issue (12): 62-67.doi: 10.16265/j.cnki.issn1003-3033.2017.12.011

褐煤露天矿端帮开采边坡支撑煤柱稳定性研究

王东¹ 教授, 姜聚宇¹, 韩新平¹ 教授, 南存全¹ 副教授, 贺希格图²

¹辽宁工程技术大学矿业学院,辽宁阜新 123000
²内蒙古霍林河露天煤业有限公司,内蒙古通辽 028000

收稿日期:2017-09-04 修回日期:2017-11-09 出版日期:2017-12-28 发布日期:2020-10-10
作者简介:王东 (1978—),男,辽宁法库人,博士,教授,博士生导师,主要从事露天开采及边坡工程领域的教学和科研工作。E-mail:lntu_wd@163.com。
基金资助:
国家自然科学基金重点资助(U1361211);国家自然科学基金资助(51474119)。

Stability of supporting coal pillar for slope highwall mined in lignite surface mine

WANG Dong¹, JIANG Juyu¹, HAN Xinping¹, NAN Cunquan¹, HE Xigetu²

¹College of Mines,Liaoning Technical University,FuxinLiaoning 123000,China
²Inner Mongolia Huolinhe Opencast Coal Industry Co., Ltd,Tongliao Inner Mongolia 028000,China

Received:2017-09-04 Revised:2017-11-09 Online:2017-12-28 Published:2020-10-10

摘要/Abstract

摘要： 为高效、安全回采露天矿开采后端帮大量压煤,综合采用理论分析、蠕变试验、数值模拟与工程实施等手段,研究端帮采煤机打硐回采条件下边坡支撑煤柱稳定性。以霍林河北矿西端帮为例,基于突变理论,推导支撑煤柱发生突变失稳的必要条件;基于支撑煤柱服务时间要求,提出目标时间强度的概念,确定支撑煤柱的3天目标时间强度参数;基于数值模拟,以煤柱拉伸剪切塑性区宽度为判据,确定合理煤柱宽度。结果表明:煤柱发生突变失稳的必要条件为煤柱塑性区宽度大于煤柱总宽度的88%;试验获得实例中煤柱的黏聚力c=0.93 MPa,内摩擦角φ=17.6°;确定合理煤柱宽度为4 m,经工程实践,验证了其合理性。

关键词: 褐煤露天矿, 端帮开采, 突变理论, 蠕变试验, 目标时间强度

Abstract: In order to recover the coal under end slope after mining, theoretical analysis, creep test, numerical simulation and engineering practice are used to study the stability of supporting coal pillar under the condition that highwall machine recovers the coal by the way of holing. With west end slope of Huolinhe North Mine as the engineering background, the necessary condition for the instability of coal pillar is deduced based on mutation theory.The concept of target time strength is put forward based on the service time of supporting coal pillar, supporting coal pillar three days target time strength parameters are determined.Numerical simulation was applied to study coal pillar stability by calculating the range of tensile and shearing plastic zone, reasonable width of coal pillar is determined.Results show that the necessary condition for the instability of coal pillar is the width of the plastic zone is 88% of the coal pillar.Supporting coal cohesion is 0.93 MPa and friction is 17.6°. Reasonable width of coal pillar is determined to be 4 m ,which is proved by engineering practice.

Key words: lignite surface mine, highwall mining, catastrophe theory, creep test, target time strength

中图分类号:

X936

王东, 姜聚宇, 韩新平, 南存全, 贺希格图. 褐煤露天矿端帮开采边坡支撑煤柱稳定性研究[J]. 中国安全科学学报, 2017, 27(12): 62-67.

WANG Dong, JIANG Juyu, HAN Xinping, NAN Cunquan, HE Xigetu. Stability of supporting coal pillar for slope highwall mined in lignite surface mine[J]. China Safety Science Journal, 2017, 27(12): 62-67.

参考文献

[1] 王守功,姚格林,包慧.露天矿端帮采煤机应用分析[J].露天采矿技术,2014(10): 28-30.
WANG Shougong, YAO Gelin, BAO Hui.Application analysis of highwall miner in open-pit mine[J].Opencast Mining Technology,2014(10): 28-30.
[2] 殷志祥,董慧.基于边坡稳定性的SHM开采端帮特厚煤层影响参数研究[J].应用基础与工程科学学报,2015,23(1): 56-67.
YIN Zhixiang,DONG Hui.Impact parameters of SHM for thick coal seam mining of open-pit slope based on slope stability[J].Journal of Basic Science and Engineering,2015,23(1): 56-67.
[3] ZIPF J,MARK C.Ground control for highwall mining in the United States[J].International Journal of Mining,Reclamation and Environment,2005,19(3): 188-217.
[4] KELLY C,WU K,WARD B,et al.Highwall stability in an open pit stone operation[C].Proceedings of the 21^st International Conference on Ground Control in Mining,2002: 228-235.
[5] 韩新平.无人智能采矿机:中国,10123925.5[P].2014- 06-18.
[6] 陈彦龙,吴豪帅.露天矿端帮开采下的支撑煤柱突变失稳机理研究[J].中国矿业大学学报,2016,45(5): 859-865.
CHEN Yanlong,WU Haoshuai.Catastrophe instability mechanism of rib pillar in open-pit highwall mining[J].Journal of China University of Mining & Technology,2016,45(5): 859-865.
[7] 曹胜根,曹洋,姜海军.块段式开采区段煤柱突变失稳机理研究[J].采矿与安全工程学报,2014,31(6): 907-913.
CAO Shenggen,CAO Yang,JIANG Haijun.Research on catastrophe instability mechanism of section coal pillars in block mining[J].Journal of Mining and Safety Engineering,2014,31(6): 907-913.
[8] 刘威,张敬军,亢方超,等.考虑煤体蠕变位移的水力扩孔合理扩煤量[J].中国安全科学学报,2017,27(3): 111-116.
LIU Wei,ZHANG Jingjun,KANG Fangchao,et al.Reasonable coal amount of hydraulic flushing borehole considering creep displacement[J].China Safety Science Journal,2017,27(3): 111-116.
[9] 贾立锋,孙维吉,梁冰,等.应力-渗流作用下煤体变形特性试验研究[J].中国安全科学学报,2016,26(3): 115-120.
JIA Lifeng,SUN Weiji,LIANG Bing,et al.Experimental study on deformation characteristics of coal under influence of stress-seepage[J].China Safety Science Journal,2016,26(3): 115-120.
[10] 王军保,刘新荣,郭建强,等.盐岩蠕变特性及其非线性本构模型[J].煤炭学报,2014,39(3): 445-451.
WANG Junbao,LIU Xinrong,GUO Jianqiang,et al.Creep properties of salt rock and its nonlinear constitutive model [J].Journal of China Coal Society,2014,39(3): 445-451.
[11] 于怀昌,李亚丽,刘汉东.粉砂质泥岩常规力学、蠕变以及应力松弛特性的对比研究[J].岩石力学与工程学报,2012,31(1): 60-70.
YU Huaichang,LI Yali,LIU Handong.Creep and stress relaxation properties of silty mudstone under triaxial compression[J].Chinese Journal of Rock Mechanics and Engineering,2012,31(1): 60-70.
[12] GB 50330—2013,建筑边坡工程技术规范[S].
GB 50330-2013,Technical code for building slope engineering[S].

[1]	姜聚宇, 杨慧雯, 王东, 王来贵. 端帮开采支撑煤柱失稳演化机制试验研究^*[J]. 中国安全科学学报, 2021, 31(10): 89-96.
[2]	韦善阳, 石美, 杨欢, 孙威. 木结构吊脚楼火灾轰燃临界值预测研究[J]. 中国安全科学学报, 2020, 30(2): 35-40.
[3]	宋守信, 陈明利, 翟怀远. 反脆弱机制在安全风险管控中的策略研究[J]. 中国安全科学学报, 2020, 30(12): 8-15.
[4]	裴甲坤, 王飞跃, 郭换换, 杨宸宇, 裴重伟. 基于改进尖点突变模型的化工事故致因分析[J]. 中国安全科学学报, 2019, 29(7): 20-25.
[5]	刘波, 肖红飞. 隧道下伏溶洞顶板安全厚度确定方法[J]. 中国安全科学学报, 2019, 29(4): 104-111.
[6]	王雨虹, 刘璐璐, 付华, 徐耀松. 基于声发射多参数时间序列的瓦斯突出预测[J]. 中国安全科学学报, 2018, 28(5): 129-134.
[7]	李玉飞, 叶义成, 刘晓云, 胡南燕, 罗斌玉, 元宙昊. 机械施工荷载作用下采空区顶板稳定性研究[J]. 中国安全科学学报, 2017, 27(7): 133-138.
[8]	李杰林, 刘伟杰, 刘汉文. 核电站土建施工风险度量模型构建与分析[J]. 中国安全科学学报, 2017, 27(5): 81-86.
[9]	赵来军，程晶晶. 基于突变理论的非常规突发事件下个体行为状态研究[J]. 中国安全科学学报, 2010, 20(12): 14-.
[10]	刘文远，陶娟. 基于突变理论的近海船舶航行安全评价[J]. 中国安全科学学报, 2010, 20(10): 113-.
[11]	李润求，施式亮，彭新. 煤矿瓦斯爆炸事故演化的突变模型[J]. 中国安全科学学报, 2008, 18(3): 22-.
[12]	李珞铭，吴超，王立磊，阳富强. 流变-突变论在预防硫化矿自燃中的应用研究[J]. 中国安全科学学报, 2008, 18(2): 81-.
[13]	林大建，蔡嗣经，周永安. 基于蝴蝶型突变理论的安全生产保障系统分析和探讨[J]. 中国安全科学学报, 2007, 17(10): 28-.
[14]	周荣义，黎忠文，牛会永. 基于突变理论的油库火灾爆炸分析与模糊动态评价[J]. 中国安全科学学报, 2006, 16(6): 97-.
[15]	王凯，位爱竹，陈彦飞，俞启香. 煤层底板突水的突变理论预测方法及其应用[J]. 中国安全科学学报, 2004, 14(1): 11-.

褐煤露天矿端帮开采边坡支撑煤柱稳定性研究

Stability of supporting coal pillar for slope highwall mined in lignite surface mine

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价