不同瓦斯压力下煤体力学特性试验研究

doi:10.16265/j.cnki.issn1003-3033.2021.03.013

中国安全科学学报 ›› 2021, Vol. 31 ›› Issue (3): 90-95.doi: 10.16265/j.cnki.issn1003-3033.2021.03.013

不同瓦斯压力下煤体力学特性试验研究

臧泽升^1,2, 李忠辉^**1,2,3 教授, 钮月^1,2, 刘帅杰^1,2, 宋晶晶^1,2, 张全聪^1,2

1 中国矿业大学煤矿瓦斯与火灾防治教育部重点实验室,江苏徐州 221116;
2 中国矿业大学安全工程学院,江苏徐州 221116;
3 中国矿业大学煤矿瓦斯治理国家工程研究中心,江苏徐州 221116

收稿日期:2020-12-16 修回日期:2021-02-19 出版日期:2021-03-28 发布日期:2021-12-20
通讯作者: **李忠辉(1978—),男,河北高邑人,博士,教授,博士生导师,主要人事矿山安全、煤岩动力灾害监测监控等方面的研究。E-mail:leezhonghui@163.com。
作者简介:臧泽升 (1997—),男,山西大同人,硕士研究生,研究方向为煤岩动力灾害监测预警技术。E-mail:zzs4205@163.com。
基金资助:
国家自然科学基金面上项目资助(51674254);山东省重大科技创新工程项目(2019JZZY020505)。

Experimental study on mechanical properties of coal under different gas pressure

ZANG Zesheng^1,2, LI Zhonghui^1,2,3, NIU Yue^1,2, LIU Shuaijie^1,2, SONG Jingjing^1,2, ZHANG Quancong^1,2

1 Key Laboratory of Gas and Fire Control for Coal Mines of Ministry of Education, China University of Mining and Technology, Xuzhou Jiangsu 221116, China;
2 School of Safety Engineering, China University of Mining and Technology, Xuzhou Jiangsu 221116, China;
3 National Engineering Research Center for Coal Gas Control, China University of Mining and Technology,Xuzhou Jiangsu 221116, China

Received:2020-12-16 Revised:2021-02-19 Online:2021-03-28 Published:2021-12-20

摘要/Abstract

摘要： 为研究瓦斯对煤体力学特性的影响,设计不同瓦斯压力条件下煤体单轴压缩试验,研究煤样力学参数及变形特征随瓦斯压力的变化趋势,探讨瓦斯对煤体力学性质的影响机制,得出单轴压缩下煤样力学参数,并记录煤样的破坏形态。研究结果表明:随瓦斯压力增大,应力-应变曲线压实阶段增大,弹性阶段缩小,失稳破坏后曲线缓慢下降,抗压强度和弹性模量单调减小,峰值应变单调增大;不含瓦斯煤样受载破坏产生的裂纹较为单一,含瓦斯煤样受载破坏后出现明显主裂纹及多向分叉裂纹,并出现局部煤体脱落现象。

关键词: 瓦斯压力, 力学特性, 单轴压缩, 变形破坏, 有效应力

Abstract: In order to study influence of gas on mechanical properties of coal, a uniaxial compression test of coal under different gas pressure was designed. Change trend of coal samples' mechanical parameters and deformation characteristics along with gas pressure was studied to explore influence mechanism of gas on their mechanical properties, their parameters under uniaxial compression were obtained, and failure mode was recorded. The results show that with increase of gas pressure, compaction stage of stress-strain curve increases while elastic stage decreases, and the curve decreases slowly after instability failure. Meanwhile, compressive strength and elastic modulus decrease monotonously while peak strain increases monotonously. Cracks of coals with no gas produced under load are relatively simple, but gas-containing coal samples, after being damaged under load, see obvious main cracks and multi-directional bifurcation cracks as well as partial coal body shedding.

Key words: gas pressure, mechanical properties, uniaxial compression, deformation and failure, effective stress

中图分类号:

X936

臧泽升, 李忠辉, 钮月, 刘帅杰, 宋晶晶, 张全聪. 不同瓦斯压力下煤体力学特性试验研究[J]. 中国安全科学学报, 2021, 31(3): 90-95.

ZANG Zesheng, LI Zhonghui, NIU Yue, LIU Shuaijie, SONG Jingjing, ZHANG Quancong. Experimental study on mechanical properties of coal under different gas pressure[J]. China Safety Science Journal, 2021, 31(3): 90-95.

参考文献

[1] 俞启香. 矿井瓦斯防治[M]. 徐州:中国矿业大学出版社,1992: 3-60.
[2] 赵敖寒,马衍坤,刘健,等.瓦斯环境中煤体破裂AE信号频带能量特征研究[J].中国安全科学学报,2020,30(3): 115-121.
ZHAO Aohan, MA Yankun, LIU Jian, et al. Energy characteristics of AE signal frequency band during coal rupture in mines with gas[J].China Safety Science Journal, 2020,30(3): 115-121.
[3] CHEN Peng,WANG Enyuan,OU Jianchun, et al.Fractal characteristics of surface crack evolution in the process of gas-containing coal extrusion[J].International Journal of Mining Science and Technology,2013,23(1): 121-126.
[4] 梁冰, 章梦涛. 煤和瓦斯突出的固流耦合失稳理论[J]. 煤炭学报, 1995, 20(5): 492-496.
LIANG Bing, ZHANG Mengtao. Theory of instability of flow fixation coupling for coal and gas outburst[J]. Journal of China Coal Society, 1995, 20(5): 492-496.
[5] 赵洪宝, 张红兵, 尹光志. 含瓦斯软弱煤三轴力学特性试验[J]. 重庆大学学报, 2013,36(1): 103-109.
ZHAO Hongbao, ZHANG Hongbing, YIN Guangzhi. Experiments on triaxial mechanical properties of soft coal containing gas[J]. Journal of Chongqing University, 2013, 36(1): 103-109.
[6] 许江, 鲜学福. 含瓦斯煤的力学特性的实验分析[J]. 重庆大学学报,1993, 16(5): 42-47.
XU Jiang, XIAN Xuefu. An experimental study on the mechanical property of the gas-filled coal[J]. Journal of Chongqing University, 1993, 16(5): 42-47.
[7] 邱兆云, 潘一山, 罗浩,等. 有效应力对煤体力学特性影响试验研究[J]. 安全与环境学报, 2016, 16(6): 54-58.
QIU Zhaoyun, PAN Yishan, LUO Hao, et al. Experimental study of the impact of the effective stress on the mechanical properties of the coal[J]. Journal of Safety and Environment, 2016, 16(6): 54-58.
[8] WANG Kai, DU Feng, ZHANG Xiang, et al. Mechanical properties and permeability evolution in gas-bearing coal-rock combination body under triaxial conditions[J]. Environmental Earth Sciences, 2017, 76(24):815.1-815.19.
[9] XIE Guangxiang, YIN Zhiqiang, WANG Lei, et al. Effects of gas pressure on the failure characteristics of coal[J]. Rock Mechanics & Rock Engineering, 2017, 50(7): 1 711-1 723.
[10] 刘泉声, 刘恺德, 朱杰兵,等. 高应力下原煤三轴压缩力学特性研究[J]. 岩石力学与工程学报, 2014, 33(1): 24-34.
LIU Quansheng, LIU Kaide, ZHU Jiebing, et al. Study of mechanical properties of raw coal under high stress with triaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering, 2014, 33(1): 24-34.
[11] ZHANG Liang, LI Xiangchun, GAO Jiaxing, et al. Creep characteristics and constitutive model of coal under triaxial stress and gas pressure[J]. Energy Science & Engineering, 2020, 8(2): 501-514.
[12] 李波波, 张尧, 任崇鸿,等. 三轴应力下煤岩损伤-能量演化特征研究[J]. 中国安全科学学报, 2019, 29(10): 98-104.
LI Bobo, ZHANG Yao, REN Chonghong, et al. Study on damage-energy evolution characteristics of coal under triaxial stress[J]. China Safety Science Journal, 2019, 29(10): 98-104.
[13] 肖晓春, 王磊, 吴迪,等. 瓦斯吸附作用下煤岩力学行为及声-电荷反演[J]. 中国安全科学学报, 2018, 28(7): 82-87.
XIAO Xiaochun, WANG Lei, WU Di, et al. Mechanical behavior and acoustic-charge inversion of coal rock under gas adsorption[J]. China Safety Science Journal, 2018, 28(7): 82-87.
[14] 林峰. 瓦斯压力对煤体蚀损规律研究[D]. 淮南: 安徽理工大学, 2018.
LIN Feng. Research on gas pressure corrosion law of coal body[D]. Huainan: Anhui University of Science & Technology, 2018.
[15] 王家臣, 邵太升, 赵洪宝. 瓦斯对突出煤力学特性影响试验研究[J]. 采矿与安全工程学报, 2011, 28(3):391-394,400.
WANG Jiachen, SHAO Taisheng, ZHAO Hongbao. Experimental study of effect of gas on mechanical properties of outburst coal[J]. Journal of Mining & Safety Engineering, 2011, 28(3):391-394,400.
[16] 卢平,沈兆武,朱贵旺,等.含瓦斯煤的有效应力与力学变形破坏特性[J].中国科学技术大学学报,2001, 31(6): 55-62.
LU Ping, SHEN Zhaowu, ZHU Guiwang, et al. The effective stress and mechanical deformation and damage characteristics of gas-filled coal[J]. Journal of China University of Science and Technology, 2011, 31(6): 55-62.

不同瓦斯压力下煤体力学特性试验研究

Experimental study on mechanical properties of coal under different gas pressure

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	辛保泉, 喻健良, 党文义, 白永忠, 于安峰. 定量风险评估视域下的多组分混合物危险特性[J]. 中国安全科学学报, 2022, 32(4): 80-85.
[2]	王亮, 孙毅民, 褚鹏, 赵伟, 邹双英. 基于时空分布特征的煤层瓦斯测压准确性研究[J]. 中国安全科学学报, 2021, 31(2): 40-47.
[3]	邹士超, 辛嵩. 煤层瓦斯钻孔有效抽采半径研究[J]. 中国安全科学学报, 2020, 30(4): 53-59.
[4]	赵敖寒, 马衍坤, 刘健, 陈德重, 袁宏永, 付明. 瓦斯环境中煤体破裂AE信号频带能量特征研究[J]. 中国安全科学学报, 2020, 30(3): 115-121.
[5]	齐消寒, 马恒, 王晓琪, 张遵国, 吕有厂. 热冲击对煤岩细观损伤及力学特性影响研究[J]. 中国安全科学学报, 2020, 30(12): 85-92.
[6]	李波波, 张尧, 任崇鸿, 杨康, 李建华, 许江. 三轴应力下煤岩损伤-能量演化特征研究[J]. 中国安全科学学报, 2019, 29(10): 98-104.
[7]	齐黎明, 祁明, 陈学习. 抽采钻孔周围煤层瓦斯压力分布理论分析及应用[J]. 中国安全科学学报, 2018, 28(7): 102-108.
[8]	张淑坤, 王树达, 王来贵, 孙琦. 结构面局部弱化影响下巷道围岩稳定性研究[J]. 中国安全科学学报, 2018, 28(7): 116-121.
[9]	宋艳芳, 潘一山, 包思远. 冲击倾向性煤体失稳破坏电荷感应问题试验研究[J]. 中国安全科学学报, 2018, 28(2): 151-157.
[10]	杨康, 李波波, 任崇鸿, 李建华, 许江, 袁梅. 温度作用下考虑过剩吸附的煤岩吸附模型[J]. 中国安全科学学报, 2018, 28(10): 137-142.
[11]	唐巨鹏, 丁佳会, 路江伟, 于宁. 考虑有效应力的煤与瓦斯突出过程分析[J]. 中国安全科学学报, 2017, 27(9): 129-133.
[12]	李传明, 刘万荣. 节理岩体巷道围岩稳定性的颗粒离散元分析[J]. 中国安全科学学报, 2017, 27(4): 133-138.
[13]	李波波, 杨康, 袁梅, 许江. 孔隙压力对煤岩渗透率影响的试验研究[J]. 中国安全科学学报, 2017, 27(3): 77-82.
[14]	高魁，刘泽功，刘健，邓东生，康亚，黄凯峰. 构造软煤的物理力学特性及其对煤与瓦斯突出的影响[J]. 中国安全科学学报, 2013, 23(2): 129-.
[15]	邵良杉，李永利，孙朋. 煤岩破裂全过程的声发射序列分形特征研究[J]. 中国安全科学学报, 2013, 23(12): 78-.