不同变质程度煤燃烧特性及动力学参数研究

doi:10.16265/j.cnki.issn1003-3033.2017.09.011

中国安全科学学报 ›› 2017, Vol. 27 ›› Issue (9): 63-68.doi: 10.16265/j.cnki.issn1003-3033.2017.09.011

不同变质程度煤燃烧特性及动力学参数研究

白刚^1,2, 周西华^**1,2 教授, 宋东平^1,2, 李雪明^1,2

1 辽宁工程技术大学安全科学与工程学院,辽宁阜新 123000
2 矿山热动力灾害与防治教育部重点实验室,辽宁阜新 123000

收稿日期:2017-06-11 修回日期:2017-07-28 出版日期:2017-09-20 发布日期:2020-11-16
通讯作者: **周西华(1968—),男,安徽淮北人,博士,教授,主要从事矿井火灾防治、瓦斯灾害防治、高温防治等方面的研究。E-mail:xihua_zhou68@163.com。
作者简介:白刚 (1991—),男,安徽宿州人,博士研究生,主要从事矿井火灾防治、瓦斯灾害防治等方面的研究。E-mail:1272661640@qq.com。
基金资助:
国家自然科学基金资助(51274115)。

Research on coal's combustion characteristics and kinetics parameters as a function of its metamorphic degree

BAI Gang^1,2, ZHOU Xihua^1,2, SONG Dongping^1,2, LI Xueming^1,2

1 College of Safety Science & Engineering,Liaoning Technical University,Fuxin Liaoning 123000, China
2 Key Laboratory of Mine Thermodynamic Disasters & Control of Ministry of Education Liaoning Technical University, Fuxin Liaoning 123000,China

Received:2017-06-11 Revised:2017-07-28 Online:2017-09-20 Published:2020-11-16

摘要/Abstract

摘要： 为研究煤的变质程度对煤矿火灾时期煤燃烧放热特性的影响,选取6种不同变质程度煤样作为试验样品,采用STA-449C型同步热分析仪进行热重(TG)试验。研究煤样的质量变化、放热量变化规律。通过对TG曲线进行一阶微分得到煤样失重速率(DTG)曲线。利用Freeman-Carrol模型计算各煤样的燃烧反应动力学参数。结果表明:失重率和最大失重速率随着煤样变质程度升高逐渐降低,DTG曲线近似符合Gauss分布;初始放热温度T_f0随着煤样水分含量升高而升高;煤样变质程度升高,特征温度点T₁,T₃,T_s1与T₄呈线性增加,T_f0与T_s0呈线性下降趋势变化;放热量随煤变质程度升高呈指数关系变化,相同温度时,煤样变质程度越高放热量越小;煤化程度越高,综合燃烧特性指数S越大,放热量越大,失水活化能、着火活化能与燃烧活化能均升高。

关键词: 变质程度, 特征温度点, 初始放热温度, 放热量, 燃烧特性指数, 动力学参数

Abstract: For the sake of studying the influence of coal metamorphic grade on the heat release characteristics of coal combustion in coal mine fires, thermogravimetric experiments were carried out on 6 coal samples different from each other in metamorphic degree by using an STA 449C type synchronous thermal analyzer. DTG curves were obtained by differential calculation of TG curves. Kinetic parameters of combustion reaction were calculated for the 6 coal samples by using Freeman-Carrol model. The results show that the weight loss rate and the maximum weight loss rate decrease gradually with the increase of the metamorphic degree of coal samples,the DTG curves accord with Gauss distribution approximately, that the higher the coal sample moisture content is, the higher the initial exothermal temperature θ_f0 will be, that with the increase of metamorphic degree of coal sample, characteristic temperatures θ₁, θ₃, θ_s1 and θ₄ increase linearly and θ_s0 and θ_f0 decrease linearly that the amount of heat released is an exponential function the degree of coalification, that at the same temperature, there is a negative correlation between the heat quantity and the metamorphic degree, and that there is a positive correlation between the degree of coalification, and the five items, composite combustion characteristic index S, the heat quantity, the filtration activation energy, the ignition activation energy and combustion activation energy.

Key words: metamorphic degree, characteristic temperature point, initial exothermic temperature, heat release, combustion characteristic index, kinetic parameters

中图分类号:

白刚, 周西华, 宋东平, 李雪明. 不同变质程度煤燃烧特性及动力学参数研究[J]. 中国安全科学学报, 2017, 27(9): 63-68.

BAI Gang, ZHOU Xihua, SONG Dongping, LI Xueming. Research on coal's combustion characteristics and kinetics parameters as a function of its metamorphic degree[J]. China Safety Science Journal, 2017, 27(9): 63-68.

参考文献

[1] 曾强.新疆地区煤火燃烧系统热动力特性研究[D].徐州: 中国矿业大学,2012.
ZENG Qiang. Study on the thermal dynamic characteristics of combustion system for coal fires in Xinjiang region[D]. Xuzhou: China University of Mining and Technology, 2012.
[2] 许涛. 煤自燃过程分段特性及机理的试验研究[D].徐州:中国矿业大学,2012.
XU Tao. Experimental study on the subsection characteristics and mechanism of spontaneous combustion of coal[D].Xuzhou: China University of Mining and Technology,2012.
[3] 王长安,刘银河,车得福.低氧浓度下煤燃烧特性的热重试验研究[J].工程热物理学报,2010,31(10): 1 786-1 788.
WANG Changan, LIU Yinhe, CHE Defu. Experimental investigation on combustion characteristics of coal in low oxygen concentration with thermogravimetry[J].Journal of Engineering Thermophysics,2010,31(10): 1 786-1 788.
[4] 曹凯,王德明. 贫氧条件煤自燃产热特性试验研究[J].中国安全科学学报,2015,25(10): 127-132.
CAO Kai,WANG Deming. Experimental study on heat release characteristics of coalspontaneous combustion under oxygen depletion condition[J]. China Safety Science Journal, 2015,25(10): 127-132.
[5] 马李洋,杨宇轩,王晓霞,等. 长焰煤贫氧燃烧放热特性参数试验研究[J].科学技术与工程,2016,16(1):10-12,16.
MA Liyang, YANG Yuxuan, WANG Xiaoxia,et al. Experimental study on exothermal parameters of long-flame coal combustion in oxygen-depleted air[J].Science Technology and Engineering, 2016,16(1):10-12,16.
[6] 屈丽娜. 煤自燃阶段特征及其临界点变化规律的研究[D].北京:中国矿业大学(北京),2013.
QU Lina. The study on the characteristics of coal spontaneous combustion stage and the critical point variation [D].Beijing: China University of Mining and Technology(Beijing), 2013.
[7] 肖旸,马砺,王振平,等.采用热重分析法研究煤自燃过程的特征温度[J]. 煤炭科学技术,2007,35(5):: 73-76.
XIAO Yang,MA Li,WANG Zhenping, et al. Research on characteristic temperature in coal spontaneous combustion with thermal gravity analysis method[J]. Coal Science and Technology, 2007,35(5): 73-76.
[8] 张斌,刘建忠,赵卫东,等. 褐煤自燃特性热重试验及动力学分析[J]. 热力发电,2014,43(6): 71-75.
ZHANG Bin, LIU Jianzhong, ZHAO Weidong, et al. Thermogravimetric experiments on and dynamic analysis of sponetaneous combustion characteristics of lignite[J].Thermal Power Generation, 2014,43(6): 71-75.
[9] GB/T 482—2008,煤层煤样采取方法[S].
GB/T 482-2008, Sampling of coal seam[S].
[10] GB 474—2008,煤样的制备方法[S].
GB/T 474-2008, Method for preparation of coal sample[S].
[11] NEVIN Selcuk, NUR Sena Yuzbasi.Combustion behaviour of turkish lignite in O₂/N₂ and O₂/CO₂ mixtures by using TGA-FTIR[J]. Journal of Analytical and Applied Pyrolysis,2011,90(2):133-139.
[12] WANG Chang an, ZHANG Xiaoming, LIU Yihe, et al. Pyrolysis and combustion characteristics of coal in oxygen fuel combustion[J]. Applied Energy,2012,97(3):264-273.
[13] 胡荣祖,史启祯.热分析动力学[M].北京:科学出版社,2008:100-101.
[14] MARÍA-JESÚS Lázaro,RAFAEL Moliner, ISABEL Suelves. Non-isothermal versus isothermal technique to evaluate kinetic parameters of coal pyrolysis[J].Journal of Analytical and Applied Pyrolysis,1998,47(2): 111-125.
[15] 郝成浩, 朱生华, 白永辉,等. CO₂气氛对胜利褐煤热解过程的影响[J]. 燃料化学学报,2017,45(3): 272-278.
HAO Chenghao, ZHU Shenghua, BAI Yonghui,et al. Effect of CO₂ on pyrolysis behavior of Shengli lignite[J]. Journal of Fuel Chemistry and Technology, 2017,45(3): 272-278.

不同变质程度煤燃烧特性及动力学参数研究

Research on coal's combustion characteristics and kinetics parameters as a function of its metamorphic degree

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 11

编辑推荐

Metrics

本文评价

[1]	王俏, 王兆丰, 马树俊, 张康佳. 冷冻取芯过程煤样温度变化特性研究[J]. 中国安全科学学报, 2021, 31(2): 76-81.
[2]	贾廷贵, 强倩, 娄和壮, 曲国娜. 不同变质程度煤样氧化自燃热特性试验研究^*[J]. 中国安全科学学报, 2021, 31(10): 62-67.
[3]	娄和壮, 贾廷贵. TG-DSC联用研究瓦斯气氛对煤自燃热特性的影响[J]. 中国安全科学学报, 2019, 29(11): 77-82.
[4]	邓康, 张英, 徐伯乐, 马出原, 牛奕. 磷酸铁锂电池组燃烧特性研究^*[J]. 中国安全科学学报, 2019, 29(11): 83-88.
[5]	沈赛丽, 蒋军成, 张文兴, 倪磊, 邹梦雅. 过氧乙酸叔丁酯热解特性分析及相容性研究[J]. 中国安全科学学报, 2018, 28(4): 133-138.
[6]	江佳佳, 杨建洲, 蒋军成, 潘勇, 潘旭海. 间氯过氧化苯甲酸热分解动力学及危险性[J]. 中国安全科学学报, 2017, 27(7): 110-114.
[7]	万伟，陈网桦，卫水爱，沈紫晨，张彩星. 偶氮二异丁腈热安全性分析与评估[J]. 中国安全科学学报, 2012, 22(8): 131-.
[8]	俞进阳，饶国宁，陈利平，姜夕博，彭金华. 烟花爆竹烟火药剂危险性评价方法[J]. 中国安全科学学报, 2012, 22(7): 72-.
[9]	张宏哲. 磷酸活性炭自燃过程反应动力学研究[J]. 中国安全科学学报, 2012, 22(5): 44-.
[10]	王慧欣，梁广荣，张宏哲. 二叔丁基过氧化物的热失控动力学研究[J]. 中国安全科学学报, 2012, 22(1): 76-.
[11]	张帆，谢传欣，张宏哲，王振刚. 化学品反应危险性分级方法研究与应用[J]. 中国安全科学学报, 2010, 20(8): 123-.