突出煤层群多次采动对底板穿层钻孔瓦斯抽采的影响

doi:10.16265/j.cnki.issn1003-3033.2020.05.011

中国安全科学学报 ›› 2020, Vol. 30 ›› Issue (5): 66-73.doi: 10.16265/j.cnki.issn1003-3033.2020.05.011

突出煤层群多次采动对底板穿层钻孔瓦斯抽采的影响

杨正凯^1,2 助理研究员, 程志恒^3,4 副研究员, 刘彦青^**5 助理研究员, 王宏冰⁴, 杨鹏⁶, 孙福龙⁴

1.煤炭科学研究总院,北京 100013;
2.中国矿业大学(北京) 能源与矿业学院,北京 100083;
3.华北科技学院安全工程学院,北京 101601;
4.华科中安科技(北京)有限公司,北京 102300;
5.煤炭科学技术研究院有限公司安全分院,北京 100013;
6.华晋焦煤有限责任公司沙曲二矿,山西柳林 033000

收稿日期:2020-02-21 修回日期:2020-04-12 出版日期:2020-05-28 发布日期:2021-01-28
通讯作者: **刘彦青(1989—)男,山西忻州人,硕士,助理研究员,主要从事煤矿瓦斯抽采治理相关科研工作。E-mail:lyqing0906@163.com。
作者简介:杨正凯(1986—),男,河南漯河人,博士研究生,助理研究员,主要从事矿山安全与灾害防治、矿山压力及岩层控制等相关研究工作。E-mail:mtkjyzk@126.com。
基金资助:
国家重点研发计划项目(2017YFC0804206);国家科技重大专项(2016ZX05067-005);中央高校基本科研业务费项目(3142019005)。

Influence of multiple mining of outburst coal seam group on gas extraction of cross-layer borehole

YANG Zhengkai^1,2, CHENG Zhiheng^3,4, LIU Yanqing⁵, WANG Hongbing⁴, YANG Peng⁶, SUN Fulong⁴

1. China Coal Research Institute, Beijing 100013, China;
2. School of Energy and Mining Engineering, China University of Mining & Technology, Beijing 100083, China;
3. School of Safety Engineering, North China Institute of Science and Technology, Beijing 101601, China;
4. Huake Zhongan Technology (Beijing) Co. Ltd., Beijing 102300;
5. Mine Safety Technology Branch of China Coal Research Institute, Beijing 100013, China;
6. Shaqu No.2. Mine of Huajin Coking Coal Co., Ltd., Liulin Shanxi 033000, China

Received:2020-02-21 Revised:2020-04-12 Online:2020-05-28 Published:2021-01-28

摘要/Abstract

摘要： 为揭示突出煤层群多次采动对底抽巷穿层钻孔瓦斯抽采效率的影响,利用Flac软件模拟分析沙曲二矿3、4、5号煤层下行开采过程中底抽巷顶板煤岩层卸压特征和围岩塑形区扩展特征,并现场实测钻孔瓦斯抽采效率。研究表明:3号煤层采动引起底抽巷顶板煤岩层卸压程度达59%以上,卸压作用最为显著,对钻孔瓦斯抽采浓度与抽采纯量的提升幅度最大;随着采动叠加作用影响,卸压程度减小,提升幅度也减小;4号煤层开采期间底抽巷顶板围岩塑性区范围扩张达到3.1 m,超过钻孔封孔长度,钻孔瓦斯混量开始逐渐增大,随采动次数增加,顶板围岩塑性区范围进一步扩展,钻孔瓦斯混量呈现逐步增大趋势;多次采动作用下钻孔瓦斯抽采体积分数和抽采纯量总体上呈逐渐下降趋势。

关键词: 煤层群, 下行开采, 穿层钻孔, 卸压瓦斯, 抽采效率

Abstract: In order to reveal influence of multiple mining of coal seam group on gas extraction efficiency of cross-layer borehole in bottom extraction roadway, Flac software was used to simulate and study pressure relief characteristics of roadway roof and expansion features of plastic area of surrounding rock during downward mining of No. 3, 4, 5 coal seam of Shaqu No.2 mine. Then, site measurement was conducted for borehole gas extraction efficiency. The results show that pressure relief degree of No.3 coal seam mining is more than 59%, indicating the most obvious pressure relief effect and largest increase rate of gas extraction concentration and purity. Along with increase of mining times, pressure relief degree and increase rate decrease. During mining of the No.4 coal seam, plastic area of surrounding rock reaches 3.1 m, exceeding borehole sealing length, and amount of gas mixture in borehole begins to increase gradually. As mining times increase, plastic area and gas mixture increase. Meanwhile, gas extraction concentration and purity of cross-layer borehole show a gradual downward trend.

Key words: coal seam group, downward mining, cross-layer borehole, pressure relief gas, extraction efficiency

中图分类号:

X936
TD712

杨正凯, 程志恒, 刘彦青, 王宏冰, 杨鹏, 孙福龙. 突出煤层群多次采动对底板穿层钻孔瓦斯抽采的影响[J]. 中国安全科学学报, 2020, 30(5): 66-73.

YANG Zhengkai, CHENG Zhiheng, LIU Yanqing, WANG Hongbing, YANG Peng, SUN Fulong. Influence of multiple mining of outburst coal seam group on gas extraction of cross-layer borehole[J]. China Safety Science Journal, 2020, 30(5): 66-73.

参考文献

[1] 马国强,陈如忠,崔刚,等. 近距离突出煤层群上保护层瓦斯综合治理技术[J]. 煤炭科学技术,2015,43(3): 52-55.
MA Guoqiang,CHEN Ruzhong,CUI Gang,et al. Gas comprehensive control technology of upper protective seam in contiguous outburst seams[J]. Coal Science and Technology,2015, 43(3): 52-55.
[2] 冀超辉.单一低透突出煤层底抽巷煤气共采技术及实践[J].矿业安全与环保,2015,42(3): 86-98.
JI Chaohui.Application and practice of coal-gas co-extraction technology by floor drainage roadway in single low-permeability outburst seam[J].Mining Safety & Environmental Protection, 2015,42(3): 86-98.
[3] 赵宁,戴广龙,张瑞.底抽巷一巷两用瓦斯治理技术实践[J].煤炭科学技术,2014,42(2):44-46,62.
ZHAO Ning, DAI Guanglong, ZHANG Rui. Practice on gas control technology of floor drainage gateway with two uses[J].Coal Science and Technology, 2014,42(2):44-46,62.
[4] 周红星,程远平,刘洪永,等.突出煤层群穿层钻孔孔群增透技术及应用[J].煤炭学报,2011,36(9): 1 515-1 518.
ZHOU Hongxing,CHENG Yuanping,LIU Hongyong,et al. Permeability improvement technology of array crossing boreholes and its application in outburst coal seam[J].Journal of China Coal Society,2011, 36(9): 1 515-1 518.
[5] 袁亮.卸压开采抽采瓦斯理论及煤与瓦斯共采技术体系[J].煤炭学报,2009,34(1): 1-8.
YUAN Liang. Theory of pressure relieved gas extraction and technique system of integrated coal production and gas extraction[J].Journal of China Coal Society, 2009,34(1): 1-8.
[6] 季文博,齐庆新,李宏艳,等. 近距离被保护卸压煤体透气性变化规律实测研究[J]. 煤炭学报,2015,40(4):830-835.
JI Wenbo,QI Qingxin,LI Hongyan,et al. Research on permeability characteristics of depressured protective layer in close-distance seam group[J]. Journal of China Coal Society, 2015,40(4): 830-835.
[7] 程志恒,齐庆新,李宏艳,等.近距离煤层群叠加开采采动应力-裂隙动态演化特征实验研究[J].煤炭学报,2016,41(2): 367-375.
CHENG Zhiheng,QI Qingxin,LI Hongyan,et al. Evolution of the superimposed mining induced stress-fissure field under extracting of close distance coal seam group[J]. Journal of China Coal Society,2016,41(2): 367-375.
[8] 薛东杰,周宏伟,孔琳,等.采动条件下被保护层瓦斯卸压增透机理研究[J].岩土工程学报,2012,34(10): 1 910-1 916.
XUE Dongjie,ZHOU Hongwei,KONG Lin,et al. Mechanism of unloading induced permeability increment of protected coal seam under mining[J]. Chinese Journal of Geotechnical Engineering,2012, 34(10): 1 910-1 916.
[9] 张勇,张春雷,赵甫. 近距离煤层群开采底板不同分区采动裂隙动态演化规律[J]. 煤炭学报,2015,40(4): 786-792.
ZHANG Yong,ZHANG Chunlei,ZHAO Fu. Dynamic evolution rules of mining-induced fractures in different floor area of short-distance coal seams[J]. Journal of China Coal Society,2015, 40(4): 786-792.
[10] 王伟,程远平,袁亮,等.深部近距离上保护层底板裂隙演化及卸压瓦斯抽采时效性[J]. 煤炭学报,2016,41(1): 138-148.
WANG Wei,CHENG Yuanping,YUAN Liang,et al. Floor fracture evolution and relief gas drainage timeliness in deeper underground short-distance upper protective coal seam extraction[J]. Journal of China Coal Society,2016,41(1): 138 -148.
[11] 刘洪涛,赵志强,张胜凯,等. 近距离煤层群围岩碎裂特征与裂隙分布关系[J]. 煤炭学报,2015,40(4): 766-773.
LIU Hongtao,ZHAO Zhiqiang,ZHANG Shengkai,et al. Relationship between failure characteristics and fracture spacing of surrounding rock of short-distance coal seams group[J]. Journal of China Coal Society,2015,40(4): 766-773.
[12] 毕瑞卿,程五一,陈学习.基于Hoek-Brown准则的底抽巷围岩松动圈分析[J].工业安全与环保,2019,45(2): 6-8.
BI Ruiqing, CHENG Wuyi, CHEN Xuexi. Analysis of surrounding rock loose zone of bottom pumping roadway based on Hoek-Brown criterion[J].Industrial Safety and Environmental Protection,2019,45(2): 6-8.
[13] 林海飞,李树刚,赵鹏翔,等.我国煤矿覆岩采动裂隙带卸压瓦斯抽采技术研究进展[J].煤炭科学技术,2018,46(1):28-35.
LIN Haifei,LI Shugang,ZHAO Pengxiang,et al.Research progress on pressure released gas drainage technology of miningcracking zone in overburden strata of coal mine in China[J].Coal Science and Technology,2018,46(1):28-35.
[14] 刘志伟,张帅.高瓦斯突出煤层底抽巷合理布置研究[J]. 煤炭科学技术,2018,46(10): 155-160.
LIU Zhiwei,ZHANG Shuai. Study on rational layout of floor gas drainage gateway in high gassy-outburst seam. [J]. Coal Science and Technology, 2018,46(10): 155-160.
[15] 程志恒,苏士龙,汪昕.近距离煤层采动裂隙场BBM-DEM模拟研究[J].煤炭科学技术,2019,47(12):1-9.
CHENG Zhiheng,SU Shilong,WANG Xin.Study on mining-induced fracture field of contiguous coal seam with BBM-DEM simulation[J].Coal Science and Technology,2019,47(12):1-9.
[16] 刘志伟,张帅.高瓦斯突出煤层底抽巷合理布置研究[J].煤炭科学技术,2018,46(10):155-160.
LIU Zhiwei,ZHANG Shuai.Study on rational layout of floor gas drainage gateway in high gassy-outburst seam[J].Coal Science and Technology,2018,46(10):155-160.
[17] 李树刚,徐培耘,赵鹏翔,等.采动裂隙椭抛带时效诱导作用及卸压瓦斯抽采[J].煤炭科学技术,2018,46(9):146-152.
LI Shugang,XU Peiyun,ZHAO Pengxiang,et al.Aging induced effect of elliptic paraboloid zone in mining cracks and pressure released gas drainage technique[J]. Coal Science and Technology, 2018,46(9):146-152.
[18] 程志恒.底抽巷穿层钻孔封孔深度与布孔间距优化研究[J].煤炭科学技术,2017,45(2): 76-82.
CHENG Zhiheng. Study on optimization of strata passing borehole sealing depth and borehole layout space in floor gas drainage gateway[J].Coal Science and Technology,2017, 45(2): 76-82.
[19] 田世祥,马瑞帅,邹义怀,等.钻孔瓦斯连续流量法测定煤巷卸压带宽度研究[J].中国安全科学学报,2020,30(3): 82-86.
TIAN Shixiang,MA Ruishuai,ZOU Yihuai,et al.Measurement of stress-relief zone width of roadway by borehole gas continuous flow method[J].China Safety Science Journal,2020,30(3):82-86.
[20] 王雨虹,刘璐璐,付华,等.基于声发射多参数时间序列的瓦斯突出预测[J].中国安全科学学报,2018,28(5): 129-134.
WANG Yuhong,LIU Lulu,FU Hua,et al.Research on acoustic emission multi-parameter time series based prediction of gas outburst[J].China Safety Science Journal,2018,28(5):129-134.
[21] 林海飞,田佳敏,刘丹,等.SDBS与CaCl₂复配液对煤体瓦斯解吸抑制效应研究[J].中国安全科学学报,2019,29(11): 149-155.
LIN Haifei,TIAN Jiamin,LIU Dan,et al.Inhibitory effect of SDBS and CaCl₂ compound solution on gas desorption of coal[J].China Safety Science Journal,2019,29(11): 149-155.
[22] 马树俊,王兆丰,任浩洋,等.低温变温条件下煤吸附瓦斯过程研究[J].中国安全科学学报,2019,29(10): 124-129.
MA Shujun,WANG Zhaofeng,REN Haoyang, et al. Study on gas adsorption process of coal at low and variable temperature[J].China Safety Science Journal, 2019,29(10): 124-129.
[23] 年军,高巍,李润芝,等.以孔代巷瓦斯抽采布孔间距模拟及试验研究[J].中国安全科学学报,2019,29(5): 117-123.
NIAN Jun,GAO Wei,LI Runzhi,et al.Simulation and experimental study on space between boreholes for gas drainage instead of roadway[J].China Safety Science Journal, 2019,29(5): 117-123.
[24] 高魁,乔国栋,刘健,等.构造复杂矿区煤与瓦斯突出瓦斯地质分析[J].中国安全科学学报,2019,29(1): 119-124.
GAO Kui,QIAO Guodong,LIU Jian,et al.Gas-geology action analysis of coal-gas outburst in complicated geological structure coal mine[J].China Safety Science Journal,2019,29(1): 119-124.

突出煤层群多次采动对底板穿层钻孔瓦斯抽采的影响

Influence of multiple mining of outburst coal seam group on gas extraction of cross-layer borehole

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 7

编辑推荐

Metrics

本文评价

[1]	张钧祥, 刘彦伟, 任培良, 韩红凯, 左伟芹. 基于蠕变效应的穿层钻孔封孔参数优化与试验研究[J]. 中国安全科学学报, 2021, 31(7): 97-104.
[2]	赵尤信, 齐庆杰, 吕有厂, 贾新雷, 张晋京. “两堵一注一排全筛网管”工艺及机制研究[J]. 中国安全科学学报, 2019, 29(8): 118-123.
[3]	苏伟伟. 近距离下邻近煤层群开采采空区瓦斯治理技术[J]. 中国安全科学学报, 2018, 28(12): 83-88.
[4]	马海峰, 王文龙, 李传明, 史文豹, 袁安营, 刘万荣. 叠加开采裂隙场演化与优势瓦斯通道形成机制[J]. 中国安全科学学报, 2017, 27(6): 133-138.
[5]	李家卓, 谭文峰, 李传明, 朱传奇, 马海峰. 近距离煤层群工作面采场围岩失稳机制与控制技术[J]. 中国安全科学学报, 2017, 27(5): 122-127.
[6]	任青山, 艾德春, 郭明涛. 复合膨胀材料研发及其在瓦斯抽采中应用的试验研究[J]. 中国安全科学学报, 2017, 27(12): 86-90.
[7]	李树清，龙祖根，罗卫东，解庆雪，赵训. 煤层群下保护层开采保护范围的数值模拟[J]. 中国安全科学学报, 2012, 22(6): 34-.