火焰羽流区细水雾利用效率及控制研究

doi:10.16265/j.cnki.issn1003-3033.2019.11.007

中国安全科学学报 ›› 2019, Vol. 29 ›› Issue (11): 39-44.doi: 10.16265/j.cnki.issn1003-3033.2019.11.007

火焰羽流区细水雾利用效率及控制研究

何明礼¹ 讲师, 章光¹ 教授, 胡少华^**1 讲师, 刘衍² 工程师

1 武汉理工大学安全科学与应急管理学院,湖北武汉 430070;
2 湖北省烟草公司十堰市公司,湖北十堰 442000

收稿日期:2019-08-10 修回日期:2019-10-11 发布日期:2020-10-30
通讯作者: ** 胡少华(1986—),男,江西万年人,博士,讲师,主要从事工程安全与应急管理研究。E-mail:sh_kxin@whu.edu.cn。
作者简介:何明礼 (1984—),男,四川绵阳人,博士研究生,讲师,主要从事细水雾高效利用技术研究。E-mail:summerhml@163.com

Study on utilization efficiency and control of water mist in flame plume areas

HE Mingli¹, ZHANG Guang¹, HU Shaohua¹, LIU Yan²

1 School of Safety Science and Emergency Management, Wuhan University of Technology, Wuhan Hubei 430070, China;
2 Shiyan City Tobacco Company, Hubei Tobacco Company, Shiyan Hubei 442000, China

Received:2019-08-10 Revised:2019-10-11 Published:2020-10-30

摘要/Abstract

摘要： 为提高细水雾的灭火效能,研究细水雾对火焰的冷却性能。建立火焰区细水雾的运动、传热与传质模型,采用此模型全面评估影响细水雾穿透距离和汽化性能的因素,提出一种合理确定液滴初始粒径和初始速度的方法,以及能够提高细水雾利用效率的射流协流细水雾系统。结果表明:各因素影响作用由大至小排序为液滴初始粒径、传热温差、液滴初始速度、火焰羽流速度;该系统能够显著提高细水雾的穿透距离,增大细水雾的汽化率。

关键词: 火焰羽流, 细水雾, 穿透距离, 汽化性能, 射流协流细水雾系统

Abstract: In order to improve fire extinguishing efficiency of water mist, its cooling effect on flame is studied. Firstly, a motion, heat and mass transfer model of water mist in flame areas were established which was utilized to evaluate factors that affected its penetration distance and vaporization performance comprehensively. Then, a method to reasonably identify initial size and velocity of droplets and a co-flow jet water mist system which could improve utilization efficiency were proposed.The results show that those factors rank according to their influence degree from high to low is initial size of droplets, heat transfer temperature difference, initial velocity of droplets, flame plume velocity. Penetration distance and vaporization rate of water mist can be significantly improved by this system.

Key words: flame plume, water mist, penetration distance, vaporization performance, co-flow jet water mist system

中图分类号:

X932

何明礼, 章光, 胡少华, 刘衍. 火焰羽流区细水雾利用效率及控制研究[J]. 中国安全科学学报, 2019, 29(11): 39-44.

HE Mingli, ZHANG Guang, HU Shaohua, LIU Yan. Study on utilization efficiency and control of water mist in flame plume areas[J]. China Safety Science Journal, 2019, 29(11): 39-44.

参考文献

[1] PANCAWARDANI F, ARINI D, YUNINDAR R P, et al. Analysis of water mist fire suppression system applied on cellulose fire[J]. Procedia Engineering, 2017, 170: 344-351.
[2] 杨克,邢志祥,纪虹,等. 超细水雾抑制甲烷爆炸的影响因素研究[J]. 中国安全科学学报, 2018, 28(11): 70-75.
YANG Ke, XING Zhixiang, JI Hong, et al. Analysis of factors influencing air-methane explosion suppression by ultrafine water mist [J]. China Safety Science Journal, 2018, 28(11): 70-75.
[3] LIU Z, CARPENTER D, KIM A K. Cooling characteristics of hot oil pool by water mist during fire suppression[J]. Fire Safety Journal, 2008, 43(4): 269-281.
[4] 张青松, 程相静, 白伟. 细水雾添加剂抑制锂电池火灾最佳浓度研究[J]. 中国安全生产科学技术, 2018, 14(5): 43-50.
ZHANG Qingsong, CHENG Xiangjing,BAI Wei. Study on optimum concentration of additives in water mist for suppression of lithium battery fire[J]. Journal of Safety Science and Technology, 2018, 14(5): 43-50.
[5] 翟毅. 油浸式变压器消防安全问题探讨[J]. 建筑电气, 2015, 34(10): 27-29.
ZHAI Yi. Discussion on fire safety problems of oil-immersed transformers[J]. Building Electricity, 2015, 34(10): 27-29.
[6] 胡清华. 高压细水雾在地铁设备用房灭火中的应用[J]. 铁道勘察, 2011(3): 107-110.
HU Qinghua. Applications of thin water fog system with high pressure for fire extinguishment of subway facility room[J]. Railway Investigation and Surveying, 2011(3): 107-110.
[7] 张天巍, 杜志明, 刘凯. 细水雾扑灭食用油火的有效性及影响因素研究[J]. 中国安全科学学报, 2015, 25(7): 55-61.
ZHANG Tianwei, DU Zhiming, LIU Kai. Study on effectiveness of water mist in suppressing cooking oil fire and factors affecting it[J]. China Safety Science Journal, 2015, 25(7): 55-61.
[8] 葛晓霞, 张学魁. 细水雾灭火系统技术研究进展[J]. 火灾科学, 2006, 2(5): 170-175.
GE Xiaoxia, ZHANG Xuekui. Review on water mist fire suppression system[J]. Fire Science, 2006, 2(5): 170-175.
[9] MAWHINNEY J R, RICHARDSON J K. A review of water mist fire suppression research and development[J]. Fire Technology, 1997, 33(1): 54-90.
[10] WIGHUS R. Extinguishment of enclosed gas fires with water sprays[J]. Nasa Sti/Recon Technical Report N, 1991, 94: 997-1 006.
[11] 黄鑫, 刘江虹, 廖光煊, 等. 细水雾扑灭油池火的临界条件[J]. 燃烧科学与技术, 2006, 12(4): 323-328.
HUANG Xin, LIU Jianghong, LIAO Guangxuan, et al. Critical condition of pool fire suppression by water mist[J]. Journal of Combustion Science and Technology, 2006, 12(4): 323-328.
[12] ZEGERS E, WILLIAMS B A, SHEINSON R S, et al. Dynamics and suppression effectiveness of monodisperse water droplets in non-premixed counterflow flames[J]. Proceedings of the Combustion Institute, 2000, 28(2): 2 931-2 937.
[13] CHELLIAH H K, LAZZARINI A K, WANIGARATHNE P C, et al. Inhibition of premixed and non-premixed flames with fine droplets of water and solutions[J]. Proceedings of the Combustion Institute, 2002, 29: 369-376.
[14] STRIZHAK P A, VOLKOV R S. The integral characteristics of the deceleration and entrainment of water droplets by the counter flow of high-temperature combustion products[J]. Experimental Thermal and Fluid Science, 2016, 75: 54-65.
[15] 张志荣, 冉景煜. 低温低速烟气中液滴破碎临界韦伯数与破碎时间分析[J]. 中国电机工程学报, 2012, 32(5): 78-85.
ZHANG Zhirong, RAN Jingyu. Analysis on critical We and breakup time during breakup of droplet in low temperature and low velocity flue gas[J]. Proceedings of the Chinese Society for Electrical Engineering, 2012, 32(5): 78-85.
[16] THOMAS G O. The quenching of laminar methane-air flames by water mists[J]. Combustion and Flame, 2002, 130(1): 147-160.
[17] RAMÍREZ C A. Summary of frictional drag coefficient relationships for spheres: evolving solution strategies applied to an old problem[J]. Chemical Engineering Science, 2017, 168: 339-343.
[18] SAZHIN S S. Advanced models of fuel droplet heating and evaporation[J]. Progress in Energy and Combustion Science, 2006, 32(2): 162-214.
[19] NOVOZHILOV V, HARVIE D, KENT J H, et al. A computational fluid dynamics study of wood fire extinguishment by water sprinkler[J]. Fire Safety Journal, 1997, 29(4): 259-282.
[20] VAARI J. A transient one-zone computer model for total flooding water mist fire suppression in ventilated enclosures[J]. Fire Safety Journal, 2002, 37(3): 229-257.
[21] VOLKOV R S, STRIZHAK P A. Motion of water droplets in the counter flow of high-temperature combustion products[J]. Heat and Mass Transfer, 2018, 54(1): 193-207.
[22] FERRAND V, BAZILE R, BOREE J, et al. Gas-droplet turbulent velocity correlations and two-phase interaction in an axisymmetric jet laden with partly responsive droplets[J]. International Journal of Multiphase Flow, 2003, 29: 195-217.
[23] MI J, NOBES D S, NATHAN G J. Influence of jet exit conditions on the passive scalar field of an axisymmetric free jet[J]. Journal of Fluid Mechanics, 2001, 432: 91-125.
[24] LAU T, NATHAN G J. Influence of stokes number on the velocity and concentration distributions in particle-laden jets[J]. Journal of Fluid Mechanics, 2014, 757: 432-457.

火焰羽流区细水雾利用效率及控制研究

Study on utilization efficiency and control of water mist in flame plume areas

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	姜桦, 刘长春, 黄林远, 吴鹏志, 邓天刁. 含水雾横向风作用下双喷口射流扩散火焰特性^*[J]. 中国安全科学学报, 2022, 32(1): 157-163.
[2]	杨克, 王壮, 邢志祥, 周越, 蒋军成. 氩气协同超细水雾抑制甲烷爆炸试验研究[J]. 中国安全科学学报, 2020, 30(7): 55-61.
[3]	柳承徽, 陈先锋, 张威, 徐乐先, 赵齐, 黄楚原. 基于PIV的气动式细水雾流场研究[J]. 中国安全科学学报, 2020, 30(7): 120-126.
[4]	何明礼, 章光, 胡少华, 王成. 高温逆气流中细水雾的行为与控制研究[J]. 中国安全科学学报, 2020, 30(11): 82-87.
[5]	苏石川, 郭晨宇, 王亮, 崔海滨, 曹佳斌. 低压含KCl细水雾抑制船舶油池火特性试验研究[J]. 中国安全科学学报, 2019, 29(4): 58-63.
[6]	庄卫强, 朱顺兵, 李勋. 惰性气体结合细水雾抑制锂离子电池燃烧试验研究[J]. 中国安全科学学报, 2019, 29(11): 51-57.
[7]	杨克, 张平, 邢志祥, 纪虹, 周越, 王壮. 含菌-无机盐超细水雾抑制甲烷爆炸试验研究[J]. 中国安全科学学报, 2019, 29(1): 62-67.
[8]	杨克, 邢志祥, 纪虹, 舒瑶, 张平, 左嘉琦. 超细水雾抑制甲烷爆炸的影响因素分析[J]. 中国安全科学学报, 2018, 28(11): 66-71.
[9]	陈健, 许开立. 改进型细水雾喷头雾化特性及灭火试验研究[J]. 中国安全科学学报, 2017, 27(7): 59-64.
[10]	沈贺坤，张强，王海娟. 闭式细水雾喷头参数对启动时间及控温效果影响研究[J]. 中国安全科学学报, 2012, 22(8): 59-.
[11]	毕明树，郑秋红，唐皓. 细水雾对障碍物遮挡火源抑制作用的数值研究[J]. 中国安全科学学报, 2010, 20(10): 72-.
[12]	魏彤彤，毕明树. 自然通风房间内细水雾与油池火作用的数值模拟[J]. 中国安全科学学报, 2009, 19(1): 58-.
[13]	牛国庆，许顺维，徐志胜. 细水雾中雾滴和高温环境的热质交换研究[J]. 中国安全科学学报, 2008, 18(9): 73-.
[14]	郑立刚，余明高，贾海林. 标准受限空间内细水雾熄灭煤油火的实验和数值模拟[J]. 中国安全科学学报, 2007, 17(1): 81-.
[15]	余明高，李定启，李志峰，柴玉才. CO2分析在含化学添加剂的细水雾灭火研究中的应用探讨[J]. 中国安全科学学报, 2006, 16(8): 82-.