Test and simulation of influence of voids on tunnel structure safety

doi:10.16265/j.cnki.issn1003-3033.2022.05.1777

Abstract

Abstract:

In order to reduce damage of voids behind lining to tunnel structure, influence of voids on safety of secondary lining structure was studied through changing parameters like number, location and size of voids by using model test and numerical simulation. The results show that safety factor of lining structure is significantly reduced by voids, especially when they exist at the same time in vault, bottom and left and right waist of the arch. Changes in safety factor of arch foot is the most obvious, which decreases by 57%. For cases of two voids at the same time, that at left and right arch waist is most unfavourable to stress of lining structure, featuring the lowest safety factor. When vault void increases from 0° to 45°, the vault bending moment changes from positive to negative, and its safety factor firstly increases and then decreases, during which, it will be the smallest when circumferential angle is 45°, only 34% of that at 15°.

Key words: void, tunnel structure, safety factor, model test, numerical simulation

ZHENG Aichen, XIANG Jinyang, HUANG Feng, JIN Chenghao, LIU Xingchen. Test and simulation of influence of voids on tunnel structure safety[J]. China Safety Science Journal, 2022, 32(5): 119-126.

Figures/Tables 17

Tab.1

Tab.2

Fig.1

Fig.2

Fig.3

Fig.4

Fig.5

Tab.3

Fig.6

Fig.7

Fig.8

Fig.9

Fig.10

Fig.11

Fig.12

Fig.13

Fig.14

References 14

[1]	吴江滨, 张顶立, 王梦恕. 铁路运营隧道病害现状及检测评估[J]. 中国安全科学学报, 2003, 13(6):49-52.
	WU Jiangbin, ZHANG Dingli, WANG Mengshu. Current damage situation of railway operation tunnels and their inspection and evaluation[J]. China Safety Science Journal, 2003, 13(6):49-52.
[2]	NAOTOSHI Y, KAZUHIKO T, TOSHIHIRO A. Three-dimensional seismic response of a cylindrical tunnel with voids behind the lining[J]. Tunnelling and Underground Space Technology, 2019, 84:399-412. doi: 10.1016/j.tust.2018.11.026
[3]	戴世伟, 刘鑫鑫, 万飞. 软岩隧道大变形事故致灾因素耦合分析[J]. 中国安全科学学报, 2021, 31(8):119-124. doi: 10.16265/j.cnki.issn1003-3033.2021.08.017
	DAI Shiwei, LIU Xinxin, WAN Fei. Coupling analysis on disaster-inducing factors for large deformation accidents in soft rock tunnels[J]. China Safety Science Journal, 2021, 31(8):119-124. doi: 10.16265/j.cnki.issn1003-3033.2021.08.017
[4]	HSIAO F Y, WANG C L, CHERN J C. Numerical simulation of rock deformation for support design in tunnel intersection area[J]. Tunneling and Underground Space Technology, 2009, 24(1): 14-21. doi: 10.1016/j.tust.2008.01.003
[5]	王述红, 王鹏宇, 刘宇, 等. 不同位置空洞条件下隧道的破坏模式试验研究[J]. 东北大学学报:自然科学版, 2020, 41(6):863-869.
	WANG Shuhong, WANG Pengyu, LIU Yu, et al. Experimental study on failure mode of tunnel model containing cavity in different locations[J]. Journal of Northeastern University: Natural Science, 2020, 41 (6): 863-869.
[6]	闵博, 张成平, 张旭, 等. 拱顶背后空洞影响下非对称连拱隧道结构裂损规律[J]. 中南大学学报:自然科学版, 2019, 50(7):1686-1695.
	MIN Bo, ZHANG Chengping, ZHANG Xu, et al. Failure laws of asymmetrical double-arch tunnels under effects of voids behind vault[J]. Journal of Central South University:Science and Technology, 2019, 50 (7): 1686-1695.
[7]	方勇, 郭建宁, 康海波, 等. 富水地层公路隧道衬砌背后空洞对结构受力的影响[J]. 岩石力学与工程学报, 2016, 35(8):1648-1658.
	FANG Yong, GUO Jianning, KANG Haibo, et al. Influence of voids behind lining on the mechanical behavior of lining structure of highway tunnel in watery strata[J]. Chinese Journal of Rock Mechanics and Engineering, 2016, 35 (8): 1648-1658.
[8]	MÜGE B I D, MOORE A S. Study of non-uniform bedding due to voids under jointed PVC water distribution pipes[J]. Geotextiles and Geomembranes, 2012, 34:39-50. doi: 10.1016/j.geotexmem.2012.01.003
[9]	李振, 李德建, 彭富强. 山岭隧道背后多空洞对衬砌结构影响分析[J]. 铁道科学与工程学报, 2016, 13(1):138-145.
	LI Zhen, LI Dejian, PENG Fuqiang. Analysis of multple voids behind mountain tunnel the lining structure[J]. Journal of Railway Science and Engineering, 2016, 13 (1): 138-145.
[10]	崔文艳, 宋建, 刘宇, 等. 不同位置空洞对隧道衬砌的力学行为分析[J]. 水利与建筑工程学报, 2011, 9(5):70-73.
	CUI Wenyan, SONG Jian, LIU Yu, et al. Analysis for mechanical properties of empty holes in different positions on tunnel lining[J]. Journal of Water Resources and Architectural Engineering, 2011, 9 (5): 70-73.
[11]	WANG Wei, LIAO Shichao, DING Peng, et al. Analysis of defect characteristic caused by cavities behind lining[J]. Advanced Materials Research, 2011, 261/262/263:1265-1269.
[12]	宋磊. 衬砌背后空洞对既有隧道受力影响研究[J]. 水利与建筑工程学报, 2017, 15(4):134-137,156.
	SONG Lei. Influence of the voids behind lining on the existing tunnel[J]. Journal of Water Resources and Architectural Engineering, 2017, 15 (4): 134-137,156.
[13]	丁謇, 刘伯成, 莫振泽, 等. 围岩空洞分布对隧道衬砌结构力学性能影响研究[J]. 南京工程学院学报:自然科学版, 2019, 17(2):25-28.
	DING Jian, LIU Bocheng, MO Zhenze, et al. Study on the influence of surrounding rock void distribution on mechanical properties of tunnel lining structure[J]. Journal of Nanjing Institute of Technology: Natural Science Edition, 2019, 17(2): 25-28.
[14]	JTG 3370.1-2018,公路隧道设计规范第一册土建工程(附条文说明)[S].
	JTG 3370.1-2018,Specifications for design of highway tunnels section 1 civil engineering[S].

类型	γ/ (kN·m^-3)	μ	E/GPa	c/kPa	φ/(°)
围岩	18.6	0.32	0.024	21.3	19.5
衬砌	23.8	0.18	0.96	—	—

方案	工况	空洞位置	空洞大小
1	1	无	长1.2 m, 高0.9 m
	2	左侧拱腰
	3	左拱腰+拱顶 +右拱腰+仰拱
2	4	拱顶+右拱腰
	5	拱顶+左拱脚
	6	左拱腰+右拱腰
3	7	拱顶	环向角度15°	高0.9 m
	8		环向角度30°
	9		环向角度45°

[1]	LI Gang, LIU Haizhen, YANG Qinghe, NIU Weifeng. Analysis on failure characteristics of coal seam floors and water inrush risks in mining under pressure [J]. China Safety Science Journal, 2022, 32(5): 68-76.
[2]	HE Xin, MA Yilong. Study on wake safety intervals of PA based on CFD [J]. China Safety Science Journal, 2022, 32(5): 77-83.
[3]	YOU Bo, MAO Cong, SHI Shiliang, LIU Heqing, LU Yi, LI Min. Research on change characteristics of environment in micro space of mine ventilation suits [J]. China Safety Science Journal, 2022, 32(5): 185-193.
[4]	FENG Gong, XIA Yuanyou, WANG Zhide, YAN Minjia. Dynamic early warning method of open-pit mine slopes based on integrated displacement information [J]. China Safety Science Journal, 2022, 32(3): 116-122.
[5]	HUO Feizhou, LIU Chang, MA Yaping, LI Ying. Study on evacuation in elderly care places considering active avoidance behavior [J]. China Safety Science Journal, 2022, 32(1): 142-148.
[6]	LU Yi, YANG Fan, LIU Huan, CHEN Jian, WANG Jinpeng, LI Wenhui. Thermal resistance calculation of aerogel fire-fighting clothing lining [J]. China Safety Science Journal, 2022, 32(1): 201-207.
[7]	LI Chunhui, WANG Mingnian, GUO Xiaohan, LIU Kerui, YU Li. Discussion on structural type of emergency rescue station without evacuation conditions outside tunnels [J]. China Safety Science Journal, 2021, 31(9): 184-190.
[8]	ZHANG Junxiang, LIU Yanwei, REN Peiliang, HAN Hongkai, ZUO Weiqin. Optimization and experimental study of sealing parameters of crossing boreholes based on creep effect [J]. China Safety Science Journal, 2021, 31(7): 97-104.
[9]	DING Houcheng, LIAN Zhixu, DENG Quanlong, JIANG Zhongan, YANG Liwei, GE Mengyuan. Research on dust removal characteristics under synergistic action of vibrating wire grid and high-pressure spray [J]. China Safety Science Journal, 2021, 31(6): 106-112.
[10]	JING Deji, JIA Xin, ZHANG Tian, MENG Xiangxi, MA Mingxing, WANG Zhiheng. Numerical simulation and experimental study on vortex blowing and suction dedusting technology during coal falling [J]. China Safety Science Journal, 2021, 31(6): 121-127.
[11]	ZHU Haohao, GUO Hailin, ZHUMAKELDI A. Research on crack propagation of pipeline inner surface defect under external force [J]. China Safety Science Journal, 2021, 31(3): 66-72.
[12]	JIANG Xuepeng, CHEN Xin'ge, GUO Kun. Study on critical velocity of lateral point smoke extraction tunnel fire [J]. China Safety Science Journal, 2021, 31(3): 105-111.
[13]	WANG Liang, SUN Yimin, CHU Peng, ZHAO Wei, ZOU Shuangying. Study on accuracy of coal seam gas pressure measurement based on its spatial and temporal distribution characteristics [J]. China Safety Science Journal, 2021, 31(2): 40-47.
[14]	ZHANG Meng, LIU Honglei, QIAO Wenguang, GAO Xun. Significant research on influencing factors of dump stability [J]. China Safety Science Journal, 2021, 31(2): 69-75.
[15]	ZHU Quanjie, ZHANG Zhen, CAO Lei, ZHANG Erhui, YANG Xinguang. Research on 3D mine shaft model construction and dynamic simulation of water inrush disaster avoiding [J]. China Safety Science Journal, 2021, 31(2): 149-157.