Effect of N2-water mist-slip device on methane explosion characteristics

doi:10.16265/j.cnki.issn1003-3033.2022.10.1861

Abstract

Abstract:

In order to further explore the synergistic explosion suppression effect among various explosion suppression technologies, the methane explosion characteristics under the combined action of no pressure (0 MPa), low pressure (0.1, 0.2 MPa) nitrogen-water mist and different elastic coefficients (0.42, 0.81 N/mm) limit slip devices were carried out on a self-built 100 mm×100 mm×1 000 mm square pipeline explosion platform. The results show that the development of the "tulip"\|shaped flame structure is hindered by the coupling effect of the nitrogen-containing water mist and the sliding device, the sliding device makes the combustion zone form a variable-capacity restricted space, its volume is proportional to the flame propagation speed, the explosion overpressure in each working condition decayed, and the decay rate of the burned area was slightly greater than that of the unburned area. Under the action of 0.1 MPa nitrogen-water mist under the two elastic coefficients, the overpressure peak in the burned area decreased by 12.92% and 16.07%, respectively, and the overpressure peak in the unburned area decreased by 11.97% and 15.12%, respectively.

Key words: methane explosion, N₂, water mist, slipping device, variable capacity restricted space

DUAN Yulong, BU Yunbing, LONG Fengying, LI Yuanbing, HUANG Jun, YU Shuwei. Effect of N₂-water mist-slip device on methane explosion characteristics[J]. China Safety Science Journal, 2022, 32(10): 83-89.

Figures/Tables 11

Fig.1

Tab.1

Fig.2

Tab.2

Fig.3

Fig.4

Tab.3

Fig.5

Tab.4

Fig.6

Tab.5

References 18

[1]	钱海林, 王志荣, 蒋军成. N₂/CO₂混合气体对甲烷爆炸的影响[J]. 爆炸与冲击, 2012, 32(4):445-448.
	QIAN Hailin, WANG Zhirong, JIANG Juncheng. Influence of N₂/CO₂ mixture on methane explosion[J]. Explosion and Shock Waves, 2012, 32(4): 445-448.
[2]	曲忠伟, 颜事龙, 李学超. 惰性介质对甲烷/空气预混气体爆炸极限的影响[J]. 爆破器材, 2016, 45(2):11-15.
	QU Zhongwei, YAN Shilong, LI Xuechao. Effect of inert gas to gas explosion limits of methane/air premixed[J]. Explosive Materials, 2016, 45(2): 11-15.
[3]	INGRAM J M, AUERILL A F, BATTERSBY P N, et al. Suppression of hydrogen-oxygen-nitrogen explosions by fine water mist: part 1. burning velocity[J]. International Journal of Hydrogen Energy, 2012, 37(24):19250-19 257. doi: 10.1016/j.ijhydene.2011.09.070
[4]	WANG Mengming, WEN Xiaoping, ZHANG Sumei, et al. Effect of metal foam mesh on flame propagation of biomass-derived gas in a half-open duct[J]. ACS Omega, 2020: DOI:10.1021/acsomega.0c03055. doi: 10.1021/acsomega.0c03055
[5]	王亚磊, 郑立刚, 于水军, 等. NaHCO₃分散状况对其抑制甲烷爆炸的影响研究[J]. 中国安全科学学报, 2018, 28(11):80-85. doi: 10.16265/j.cnki.issn1003-3033.2018.11.013
	WANG Yalei, ZHENG Ligang, YU Shuijun, et al. Effect of dispersion condition of NaHCO₃ on inhibiting methane-air mixture explosion[J]. China Safety Science Journal, 2018, 28(11): 80-85. doi: 10.16265/j.cnki.issn1003-3033.2018.11.013
[6]	何昆. 初始温度对氮气抑爆性能影响的实验研究[J]. 消防科学与技术, 2014, 33(11):1247-1250.
	HE Kun. Experimental study on effect of explosion suppression of nitrogen at different initial temperatures[J]. Fire Science and Technology, 2014, 33(11): 1247-1250.
[7]	陈金健, 胡双启, 曹雄. 多元惰气对瓦斯爆炸特性影响的实验研究[J]. 煤炭技术, 2015, 34(8):161-164.
	CHEN Jinjian, HU Shuangqi, CAO Xiong. Experimental research on influence of gas explosion characteristics by multiple inert gas[J]. Coal Technology, 2015, 34(8): 161-164.
[8]	ZAHEDI P, YOUSEFI K. Effects of pressure and carbon dioxide, hydrogen and nitrogen concentration on laminar burning velocities and NO formation of methane-air mixtures[J]. Journal of Mechanical Science & Technology, 2014, 28(1): 377-386.
[9]	LU Chang, WANG Hongbo, PAN Rongkun, et al. Preventing the propagation of gas explosion in ducts using spurted nitrogen[J]. Process Safety and Environmental Protection, 2019, 123: 11-23. doi: 10.1016/j.psep.2018.12.028
[10]	李振峰, 王天政, 安安, 等. 细水雾抑制煤尘与瓦斯爆炸实验[J]. 西安科技大学学报, 2011, 31(6):698-702, 707.
	LI Zhenfeng, WANG Tianzheng, AN An, et al. Experiments on the suppression of coal dust and gas explosion by water mist[J]. Journal of Xi'an University of Science and Technology, 2011, 31(6): 698-702, 707.
[11]	杨克, 邢志祥, 纪虹, 等. 超细水雾抑制甲烷爆炸的影响因素分析[J]. 中国安全科学学报, 2018, 28(11):66-71. doi: 10.16265/j.cnki.issn1003-3033.2018.11.011
	YANG Ke, XING Zhixiang, JI Hong, et al. Analysis of factors influencing air-methane explosion suppression by ultrafine water mist[J]. China Safety Science Journal, 2018, 28(11): 66-71. doi: 10.16265/j.cnki.issn1003-3033.2018.11.011
[12]	杨春丽, 刘艳, 胡玢, 等. 氮气和水蒸气对瓦斯爆炸基元反应的影响及抑爆机理分析[J]. 高压物理学报, 2017, 31(3):301-308.
	YANG Chunli, LIU Yan, HU Bin, et al. Effect of nitrogen and water vapor on methane-air mixture explosion elementary reaction and suppression mechanism[J]. Chinese Journal of High Pressure Physics, 2017, 31(3): 301-308.
[13]	PEI Bei, YU Minggao, CHEN Liwei, et al. Experimental study on the synergistic inhibition effect of nitrogen and ultrafine water mist on gas explosion in a vented duct[J]. Journal of Loss Prevention in the Process Industries, 2016, 40: 546-553. doi: 10.1016/j.jlp.2016.02.005
[14]	曹兴岩, 任婧杰, 毕明树, 等. 超细水雾雾化方式对甲烷爆炸过程影响的实验研究[J]. 煤炭学报, 2017, 42(7):1795-1802.
	CAO Xingyan, REN Jingjie, BI Mingshu, et al. Experimental study on effect of methane explosion process by atomization method of ultrafine water mist[J]. Journal of China Coal Society, 2017, 42(7): 1795-1802.
[15]	DUAN Yulong, YANG Yanling, LI Yuanbing, et al. Influence of initial position of sliding device on premixed methane/air gas explosion flame at driving face in coal mine[J]. Combustion Science and Technology, 2021:DOI: 10.1080/00102202.2021.1932851. doi: 10.1080/00102202.2021.1932851
[16]	陈敏剑. 聚甲醛纳米材料的开发及性能研究[D]. 成都: 四川大学, 2005.
	CHEN Minjian. Development and performance research of polyoxymethylene nanomaterials[D]. Chengdu: Sichuan University, 2005.
[17]	ANANTH R, WILLAUER H D, FARLEY J P, et al. Effects of fine water mist on a confined blast[J]. Fire Technology, 2012, 48(3): 641-675. doi: 10.1007/s10694-010-0156-y
[18]	余明高, 杨勇, 裴蓓, 等. N₂双流体细水雾抑制管道瓦斯爆炸实验研究[J]. 爆炸与冲击, 2017, 37(2):194-200.
	YU Minggao, YANG Yong, PEI Bei, et al. Experimental study of methane explosion suppression by nitrogen twin-fluid water mist[J]. Explosion and Shock Waves, 2017, 37(2): 194-200.

压力/ MPa	喷雾接触火焰时间/ms	火焰回退时间/ms	火焰焠熄时间/ms
0	—	85	190
0.1	41	81	154
0.2	40	83	160

压力/ MPa	喷雾接触火焰时间/ms	火焰回退时间/ms	火焰焠熄时间/ms
0	—	78	140
0.1	41.5	72	145
0.2	42	73	155

C_e/ (N·mm^-1)	压力/ MPa	速度峰值/ (m·s^-1)	峰值下降率/%
0.42	0	12.53	0
	0.1	12.99	-3.67
	0.2	13.36	-6.62
C_e/ (N·mm^-1)	压力/ MPa	速度峰值/ (m·s^-1)	峰值下降率/%
0.81	0	13.74	0
	0.1	12.07	12.15
	0.2	12.67	7.79

C_e/ (N·mm^-1)	压力/ MPa	P'₁/ kPa	P'₁下降率/%	P'₂/ kPa	P'₂下降率/%
0.42	0	19.51	0	14.28	0
	0.1	16.99	12.92	12.57	11.97
	0.2	18.15	6.97	13.36	6.44
C_e/ (N·mm^-1)	压力/ MPa	P″₁/ kPa	P″₁下降率/%	P″₂/ kPa	P″₂下降率/%
0.81	0	23.64	0	13.82	0
	0.1	19.84	16.07	11.73	15.12
	0.2	21.61	8.59	12.68	8.25

Effect of N₂-water mist-slip device on methane explosion characteristics

RichHTML

PDF

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 11

References 18

Related Articles 15

Recommended Articles

Metrics

Comments

序号	C_e/ (N·mm^-1)	压力/ MPa	雾通量/ (g·min^-1)
1	0.42	0	0
2	0.42	0.1	109.74
3	0.42	0.2	149.60
4	0.81	0	0
5	0.81	0.1	109.74
6	0.81	0.2	149.60

[1]	WANG Xiaoling, LIU Zhenqi. Study on explosion suppression characteristics of water mist containing potassium compounds outside methane-air premixed area [J]. China Safety Science Journal, 2024, 34(1): 150-157.
[2]	HONG Lin, WANG Wenjing, GAO Dameng, GUO Yingchao, MA Honghai. Influence of coal rank on CPSD in low-temperature N₂ adsorption [J]. China Safety Science Journal, 2022, 32(4): 51-58.
[3]	LUO Zhenmin, WANG Xin, WANG Tao, MENG Ziqi, WANG Zijin. Experimental study on synergetic fire extinguishing performance of water mist and inert gas [J]. China Safety Science Journal, 2022, 32(10): 63-68.
[4]	JIANG Hua, LIU Changchun, HUANG Linyuan, WU Pengzhi, DENG Tiandiao. Investigation on characteristics of dual nozzle jet diffusion flame under cross-wind with water mist [J]. China Safety Science Journal, 2022, 32(1): 157-163.
[5]	WANG Yan, LIN Sen, LI Zhong, WEN Xiaoping, ZHENG Ligang , JI Wentao. Influence of dispersion pressure on methane explosion suppression effect of KHCO₃ cold aerosol [J]. China Safety Science Journal, 2021, 31(7): 70-75.
[6]	LIU Chenghui, CHEN Xianfeng, ZHANG Wei, XU Lexian, ZHAO Qi, HUANG Chuyuan. Research on pneumatic water mist flow field based on PIV [J]. China Safety Science Journal, 2020, 30(7): 120-126.
[7]	YANG Ke, WANG Zhuang, XING Zhixiang, ZHOU Yue, JIANG Juncheng. Experimental study on synergistic gas explosion suppression by argon and ultra-fine water mist [J]. China Safety Science Journal, 2020, 30(7): 55-61.
[8]	LUO Zhenmin, WANG Zijin, SU Bin, LI Kui, SHI Jing. Influence of multi-component combustible gases on explosion characteristics and free radical emission spectrum of CH₄ [J]. China Safety Science Journal, 2020, 30(4): 1-7.
[9]	HE Mingli, ZHANG Guang, HU Shaohua, WANG Cheng. Study on behavior and control of droplets in high-temperature counter gas [J]. China Safety Science Journal, 2020, 30(11): 82-87.
[10]	SU Shichuan, GUO Chenyu, WANG Liang, CUI Haibin, CAO Jiabin. Experimental research on low-pressure water mist in suppressing ship oil pool fire effectiveness with KCl [J]. China Safety Science Journal, 2019, 29(4): 58-63.
[11]	ZHUANG Weiqiang, ZHU Shunbing, LI Xun. Experimental study on inhibition of lithium ion battery combustion by inert gas combined with water mist [J]. China Safety Science Journal, 2019, 29(11): 51-57.
[12]	HE Mingli, ZHANG Guang, HU Shaohua, LIU Yan. Study on utilization efficiency and control of water mist in flame plume areas [J]. China Safety Science Journal, 2019, 29(11): 39-44.
[13]	YANG Ke, ZHANG Ping, XING Zhixiang, JI Hong, ZHOU Yue, WANG Zhuang. Experimental study on suppression of methane explosion with ultra-fine water mist containing both optimized methane oxidizing bacteria and inorganic salt [J]. China Safety Science Journal, 2019, 29(1): 62-67.
[14]	YANG Ke, XING Zhixiang, JI Hong, SHU Yao, ZHANG Ping, ZUO Jiaqi. Analysis of factors influencing air-methane explosion suppression by ultrafine water mist [J]. China Safety Science Journal, 2018, 28(11): 66-71.
[15]	CHEN Jian, XU Kaili. Experimental study on spraying characteristics and extinguishing performance of improved water mist nozzle [J]. China Safety Science Journal, 2017, 27(7): 59-64.