倾斜XPS板材向外多向耦合蔓延燃烧特性研究

doi:10.16265/j.cnki.issn1003-3033.2019.11.011

中国安全科学学报 ›› 2019, Vol. 29 ›› Issue (11): 64-70.doi: 10.16265/j.cnki.issn1003-3033.2019.11.011

倾斜XPS板材向外多向耦合蔓延燃烧特性研究

笪良军, 谢启源^** 副研究员, 罗圣峰

中国科学技术大学火灾科学国家重点试验室,安徽合肥 230027

收稿日期:2019-08-17 修回日期:2019-10-13 出版日期:2019-11-28
作者简介:笪良军 (1993—),男,安徽桐城人,硕士研究生,研究方向为固体火蔓延。E-mail:daliangj@mail.ustc.edu.cn。
基金资助:
国家自然科学基金资助(51476157);“十三五”国家重点研发项目(2017YFC0805901);中央高校基本科研业务费专项资金资助(WK2320000041)。

Study on characteristics of multi-direction coupling flame spread and combustion after central ignition of inclined XPS sheets

DA Liangjun, XIE Qiyuan, LUO Shengfeng

State Key Laboratory of Fire Science, University of Science and Technology of China, Hefei Anhui 230027,China

Received:2019-08-17 Revised:2019-10-13 Published:2019-11-28

摘要/Abstract

摘要： 为探究热塑性板材被点火源引燃后向四周火蔓延的行为特征,针对不同倾角的方形挤塑聚苯乙烯(XPS)泡沫板材,开展中心引燃后火焰向不同方向蔓延燃烧的试验,分析火蔓延状态、火蔓延速度和内部温度场随倾斜角度的变化关系。结果表明:XPS材料在受热时产生的收缩行为导致上方预热区接收热量变化,使得倾斜角度大的板材向上火蔓延更困难;当发生向上火蔓延时,蔓延速度随倾角的增大而增大,且速度远大于横向和向下火蔓延速度;向下火蔓延速度随倾斜角度的增大呈先降低后增大的趋势,横向火蔓延受板材倾角影响较小;当材料受热时温升剧烈,则易形成材料向该点处火蔓延,反之,材料受热出现显著收缩而温升较慢,则易熄灭。

关键词: 挤塑聚苯乙烯(XPS)泡沫板材, 倾斜角度, 中心引燃, 内部温度场, 多向耦合火蔓延

Abstract: For the sake of studying development characteristics of thermoplastic sheets' flame spread after central ignition, a series of experiments were conducted on square XPS foam sheets at different inclination angles, and correlation between flame spread condition, velocity and the internal temperature was analyzed. The results show that the shrinkage after central ignition causes change of energy received in preheated zone, thus making upward flame spread more difficult along sheets with bigger inclination angle. In addition, when inclination angle is getting greater, velocities of upward flame spread increase, which is also greater than those of downward and horizontal flame spread. Besides, velocities of downward flame spread decrease firstly and then increase while horizontal flame spread velocities are less affected by inclination angle. It is also found that flame spread is sustainable if there is a violent temperature rise after heating. On the contrary, it is easy to extinguish if XPS foam shrinks significantly with a slow temperature rise.

Key words: extruded polystyrene (XPS) foam sheet, inclination angle, central ignition, internal temperature field, multi-direction coupling flame spread

中图分类号:

X932

笪良军, 谢启源, 罗圣峰. 倾斜XPS板材向外多向耦合蔓延燃烧特性研究[J]. 中国安全科学学报, 2019, 29(11): 64-70.

DA Liangjun, XIE Qiyuan, LUO Shengfeng. Study on characteristics of multi-direction coupling flame spread and combustion after central ignition of inclined XPS sheets[J]. China Safety Science Journal, 2019, 29(11): 64-70.

参考文献

[1] DERIS J N. The spread of laminar diffusion flame [J]. Symposium on Combustion,1969, 12(1): 241-252.
[2] SIRIGNANO W A. A critical discussion of theories of flame spread across solid and liquid fuels [J]. Combustion Science and Technology,1972, 6(1/2): 95-105.
[3] BHATTACHARJEE S, ALTENKIRCH R A, SRIKANATAICH N, et al. A theoretical description of flame spread over solid combustibles in a quiescent environment at zero gravity [J]. Combustion Science and Technology,1990, 69: 1-15.
[4] WICHMAN I, WILLIAMSA F, GLASSMANA I. Theoretical aspects of flame spread in an opposed-flow over flat surfaces of solid fuels [J]. Symposium (International) on Combustion,1982, 19(1): 835-845.
[5] FERNANDEZ-PELLO A C, RAYA S R, GLASSMANA I. Flame spread in an opposed forced flow: the effect of ambient oxygen concentration [J]. Symposium (International) on Combustion,1981, 18(1): 579-589.
[6] QUINTIERE J, HARKLEROAD M, WALTON D. Measurement of material flame spread properties [J]. Combustion Science and Technology,1983, 32(1/2/3/4): 67-89.
[7] DELICHATSIOS M A. Exact solution for the rate of creeping flame spread over thermally thin materials [J]. Combustion Science and Technology, 1986, 44(5/6): 257-267.
[8] ZHENG Guanyu, WICHMAN I S, BENARD A. Opposed-flow flame spread over polymeric materials: Influence of phase change [J]. Combustion and Flame, 2001, 124(3): 387-408.
[9] XIE Qiyuan, TU Ran, WANG Nan, et al. Experimental study on flowing burning behaviors of a pool fire with dripping of melted thermoplastics [J]. Journal of Hazard Materials,2017, 267: 48-54.
[10] XIE Qiyuan, ZHANG Heping, YE Ruibo. Experimental study on melting and flowing behavior of thermoplastics combustion based on a new setup with a T-shape trough [J]. Journal of Hazard Materials, 2009, 166(2/3): 1 321-1 325.
[11] LUO Shengfeng, XIE Qiyuan, TANG Xinyi, et al. A quantitative model and the experimental evaluation of the liquid fuel layer for the downward flame spread of XPS foam [J]. Journal of Hazard Materials, 2017, 329: 30-37.
[12] 王楠. 典型热塑性材料火灾行为中融流燃烧过程的试验研究[D]. 合肥:中国科学技术大学,2014.
WANG Nan. Experimental research of the flowing combustion process of typically thermoplastic materials[D]. Hefei: University of Science and Technology of China,2014.
[13] AN Weiguang, SUN Jinhua, LIEW K M, et al. Effects of building concave structure on flame spread over extruded polystyrene thermal insulation material [J]. Applied Thermal Engineering, 2017, 121: 802-809.
[14] ZHANG Ying, YIN Yi. Experimental study on the characteristics of horizontal flame spread over XPS surface on plateau [J]. Journal of Hazardous Materials,2011, 189(1/2): 34-39.
[15] JIANG Lin, SUN Jinhua. Theoretical and experimental study of width effects on horizontal flame spread over extruded and expanded polystyrene foam surfaces [J]. Journal of Fire Sciences, 2014, 32(3): 193-209.
[16] ZHANG Ying, SUN Jinhua, HUANG Xinjie. Heat transfer mechanisms in horizontal flame spread over wood and extruded polystyrene surfaces [J]. International Journal of Heat and Mass Transfer, 2013, 61: 28-34.
[17] WILLIAMS F A. Mechanisms of fire spread[J]. Symposium (International) on Combustion,1977, 16(1): 1 281-1 294.
[18] LUO Shengfeng, XIE Qiyuan, QIU Rong. Melting and dripping flow behaviors on the downward flame spread of a wide XPS foam[J]. Fire Technology, 2019, 55: 2 055-2 086.

倾斜XPS板材向外多向耦合蔓延燃烧特性研究

Study on characteristics of multi-direction coupling flame spread and combustion after central ignition of inclined XPS sheets

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李森, 王少鹏, 林锦, 陆守香, 李倩, 陈国庆. 扁平大空间船舶火灾烟气控制试验研究[J]. 中国安全科学学报, 2024, 34(5): 162-167.
[2]	刘淳元, 张国维, 杨林, 欧阳晨亮, 张作睿. 水凝胶对三元锂电池热失控抑制效果研究[J]. 中国安全科学学报, 2024, 34(5): 186-194.
[3]	张颖, 黄国洪, 龙雨娇. 高层建筑不同外保温立面结构火蔓延模拟研究[J]. 中国安全科学学报, 2024, 34(5): 122-128.
[4]	彭敏, 潘翔骁, 何坤, 李忠辉, 朱国庆. 侧向多开口轨道列车火灾烟气输运特性[J]. 中国安全科学学报, 2024, 34(5): 129-138.
[5]	张明振, 段江忠, 梁肇伟, 郭俊杰, 柴大山. 基于改进YOLO-V5算法的烟火检测方法[J]. 中国安全科学学报, 2024, 34(5): 155-161.
[6]	张莉聪, 李斯曼. 基于基元反应的气液两相协同抑爆阻燃效果分析[J]. 中国安全科学学报, 2024, 34(3): 101-108.
[7]	徐永亮, 孙萌, 王兰云, 王云刚. 矿井带式输送机火灾烟流特性及其预警防控综述[J]. 中国安全科学学报, 2024, 34(3): 117-128.
[8]	康文东, 鲁义, 张作彬, 李贺, 邢宇霆, 周钦云. 无机盐与多糖复配对泡沫灭火剂理化性能影响[J]. 中国安全科学学报, 2024, 34(3): 137-147.
[9]	陈大伟, 庞世俊, 郗艳红. 低真空隧道列车车厢内部火灾乘客疏散方案[J]. 中国安全科学学报, 2024, 34(3): 186-191.
[10]	白杨阳, 刘长春, 李存英, 艾国栋, 刘思齐, 宋方智. 基于欧拉法的消防水炮射流轨迹模型[J]. 中国安全科学学报, 2024, 34(3): 200-205.
[11]	张少禹, 王玥, 董海斌, 陈晔. 锂电池热失控爆炸超压及液氮惰化效果分析[J]. 中国安全科学学报, 2024, 34(3): 39-44.
[12]	胡洋, 陶红, 宋民航, 吕硕, 张海霞. 长直管道预混气体爆燃波系演化过程研究[J]. 中国安全科学学报, 2024, 34(3): 55-62.
[13]	马天明, 黄楚原, 陈先锋. 考虑碳排放的危险品运输异构车辆路径问题研究[J]. 中国安全科学学报, 2024, 34(1): 193-199.
[14]	彭善碧, 李薇, 唐平. 基于FLACS的地下暗厨房燃气爆炸数值模拟[J]. 中国安全科学学报, 2024, 34(1): 215-222.
[15]	王晓玲, 刘震起. 甲烷-空气预混区外含钾细水雾抑爆特性研究[J]. 中国安全科学学报, 2024, 34(1): 150-157.