电厂烟道气预防遗煤自燃的合理含氧量模拟研究

doi:10.16265/j.cnki.issn1003-3033.2017.03.008

中国安全科学学报 ›› 2017, Vol. 27 ›› Issue (3): 42-47.doi: 10.16265/j.cnki.issn1003-3033.2017.03.008

电厂烟道气预防遗煤自燃的合理含氧量模拟研究

黄戈¹, 王继仁¹ 教授, 邓存宝² 教授, 郝朝瑜¹ 副教授, 王鑫阳³ 副教授

1 辽宁工程技术大学安全科学与工程学院,辽宁阜新 123000
2 辽宁工程技术大学安全工程技术研究院,辽宁阜新 123000
3 辽宁工程技术大学矿业学院,辽宁阜新 123000

收稿日期:2016-12-11 修回日期:2017-01-18
作者简介:黄戈 (1988—),男,河北廊坊人,博士研究生,研究方向为矿井瓦斯灾害防治和防灭火等。E-mail:hg_email@foxmail.com。
基金资助:
国家自然科学基金面上项目资助(51174108,51574143);山西省科技重大专项项目(20111101017)。

Numerical simulation of reasonable oxygen content in flue gas for preventing residual coal spontaneous combustion

HUANG Ge¹, WANG Jiren¹, DENG Cunbao², HAO Chaoyu¹, WANG Xinyang³

1 College of Safety Science and Engineering,Liaoning Technical University,Fuxin Liaoning 123000,China
2 Safety Engineering Technology Research Institute,Liaoning Technical University,Fuxin Liaoning 123000,China
3 College of Mining Engineering,Liaoning Technical University,Fuxin Liaoning 123000,China

Received:2016-12-11 Revised:2017-01-18

摘要/Abstract

摘要： 为确定电厂烟道气用于遗煤自燃预防的含氧量参数,以塔山坑口电厂及塔山煤矿8105工作面为原型,建立基于计算流体力学(CFD)和煤氧复合理论的遗煤自燃三维数值模型。采用数值模拟方法,研究多场耦合条件下,含氧量为3%~9%的烟道气注入采空区后的运移状态以及氧浓度场和温度场的变化规律。结果表明,注入烟道气能够有效惰化采空区遗煤,随注入烟道气含氧量降低,氧化带最大宽度的减小符合Boltzmann函数曲线,同时,遗煤最高温度呈指数下降趋势。降低烟道气含氧量有助于提升遗煤惰化水平,以实测注氮后采空区氧化带宽度为指标,确定7.08%为烟道气用于预防采空区遗煤自燃的合理含氧量上限。

关键词: 采空区; 遗煤自燃; 电厂烟道气; 合理含氧量; 数值模拟

Abstract: In order to determine the reasonable oxygen content in flue gas for preventing spontaneous combustion of residual coal in gob, a 3D numerical model, based on Computational Fluid Dynamics (CFD) and theory of coal-oxygen reaction, was built to simulate the residual coal's spontaneous combustion in top coal caving gob area in panel 8105 of Tashan Coal Mine. The migration of flue gas in gob, distribution of “three zones” of spontaneous combustion and temperature field with 3%-9% of O₂ content in flue gas were analyzed by numerical simulation. The results show that the injected flue gas can inert spontaneous combustion of the residual coal effectively. Along with decrease of oxygen content in the flue gas injected, the maximum width of the oxidation zone will decrease accordingly which is agreed with the curve of Boltzmann function and the maximum temperature of the residual coal will decrease exponentially. Lowering oxygen content in flue gas will improve the inerting effect of the residual coal. Based on the field measured data of the width of oxidation zone after nitrogen was injected, oxygen content is determined to be 7.08% as the reasonable upper limit in the flue gas for preventing spontaneous combustion of residual coal in gob.

Key words: gob, residual coal's spontaneous combustion, flue gas, reasonable oxygen content, numerical simulation

中图分类号:

X936

黄戈, 王继仁, 邓存宝, 郝朝瑜, 王鑫阳. 电厂烟道气预防遗煤自燃的合理含氧量模拟研究[J]. 中国安全科学学报, 2017, 27(3): 42-47.

HUANG Ge, WANG Jiren, DENG Cunbao, HAO Chaoyu, WANG Xinyang. Numerical simulation of reasonable oxygen content in flue gas for preventing residual coal spontaneous combustion[J]. China Safety Science Journal, 2017, 27(3): 42-47.

参考文献

[1] 梁运涛, 罗海珠. 中国煤矿火灾防治技术现状与趋势[J]. 煤炭学报, 2008, 33(2): 126-130.
LIANG Yuntao, LUO Haizhu. Current situation and development trend for coal mine fire prevention & extinguishing techniques in China[J]. Journal of China Coal Society, 2008, 33(2): 126-130.
[2] 牛会永, 周心权. 综放面采空区遗煤自然发火特点及环境分析[J]. 煤矿安全, 2008, 39(8): 12-15.
NIU Huiyong, ZHOU Xinquan. Analyzing on surroundings and characteristics of coal self-ignition in goaf in a fully mechanized top-coal caving face[J]. Safety in Coal Mines, 2008, 39(8): 12-15.
[3] 尚帅超. 电厂烟气预防自燃与封存的可行性研究[D]. 阜新:辽宁工程技术大学, 2009.
SHANG Shuaichao. Feasibility study of the power plant haze been to prevent spontaneous combustion and sealed[D]. Fuxin: Liaoning Technical University, 2009.
[4] 高飞, 邓存宝, 王雪峰, 等. 常温常压下采空区遗煤对电厂烟气的吸附[J]. 环境工程学报, 2016, 10(4): 1 907-1 912.
GAO Fei, DENG Cunbao, WANG Xuefeng, et al. Adsorption of power plant flue gas by abandoned coal at normal temperature and pressure[J]. Chinese Journal of Environmental Engineering, 2016, 10(4): 1 907-1 912.
[5] 高飞, 邓存宝, 王雪峰, 等. 电厂烟气注入采空区封存的可行性[J]. 环境科学研究, 2016, 29(7): 1 096-1 100.
GAO Fei, DENG Cunbao, WANG Xuefeng, et al. Feasibility analysis on seal of power plant smoke injected into the goaf[J]. Research of Environmental Sciences, 2016, 29(7): 1 096-1 100.
[6] 邵昊, 蒋曙光, 吴征艳, 等. 采空区注二氧化碳防灭火的数值模拟研究[J]. 采矿与安全工程学报, 2013, 30(1): 154-158.
SHAO Hao, JIANG Shuguang, WU Zhengyan, et al. Numerical simulation on fire prevention by infusing carbon dioxide into goaf[J]. Journal of Mining & Safety Engineering, 2013, 30(1): 154-158.
[7] 郝朝瑜, 王继仁, 黄戈, 等. 基于惰化降温耦合作用的采空区低温CO₂注入位置研究[J]. 中国安全生产科学技术, 2015, 11(9): 17-23.
HAO Chaoyu, WANG Jiren, HUANG Ge, et al. Study on inject position of low temperature CO₂ in gob based on coupling effect of inerting cooling[J]. Journal of Safety Science and Technology, 2015, 11(9): 17-23.
[8] 王继仁, 张英, 郝朝瑜. 半“O”型冒落采空区注CO₂防灭火的数值模拟[J]. 中国安全科学学报, 2015, 25(7): 48-54.
WANG Jiren,ZHANG Ying,HAO Chaoyu. Numerical simulation of fire prevention in gob area with half O-ring risked falling by CO₂ injection[J]. China Safety Science Journal, 2015, 25(7): 48-54.
[9] 罗新荣, 唐冠楚, 李亚伟, 等. CFD模型下采空区瓦斯抽采与注氮防灭火设计[J]. 中国安全科学学报, 2016, 26(6): 69-74.
LUO Xinrong, TANG Guanchu, LI Yawei, et al. CFD model based design of both gas drainage and nitrogen injection against fire in goaf[J]. China Safety Science Journal, 2016, 26(6): 69-74.
[10] 董强, 周西华, 李昂, 等. 低透自燃煤层综放采空区瓦斯与火共治方法研究[J]. 中国安全科学学报, 2016, 26(7): 41-45.
DONG Qiang, ZHOU Xihua, LI Ang, et al. A method for dealing with both gas and fire in low permeability and spontaneous combustion seam full-mechanized mine goaf[J]. China Safety Science Journal, 2016, 26(7): 41-45.
[11] 贾宝山, 尹彬, 闫玉岗, 等. 煤矿坑口电厂烟道气用于采空区防灭火技术研究[J]. 中国安全生产科学技术, 2014, 10(7): 49-54.
JIA Baoshan, YIN Bin, YAN Yugang, et al. Research on technology of applying the flue gas of pithead power plant to fire prevention and extinguishing in goaf[J]. Journal of Safety Science and Technology, 2014, 10(7): 49-54.
[12] 贾宝山, 尹彬, 张卫亮, 等. 烟道气预防采空区自燃的数值模拟及参数确定[J]. 采矿与安全工程学报, 2015, 32(6): 1 043-1 048.
JIA Baoshan, YIN Bin, ZHANG Weiliang, et al. Numerical simulation and parameter determination in goaf spontaneous combustion prevention by injecting flue gas[J]. Journal of Mining & Safety Engineering, 2015, 32(6): 1 043-1 048.
[13] 王国旗, 邓军, 张辛亥, 等. 综放采空区二氧化碳防灭火参数确定[J]. 辽宁工程技术大学学报: 自然科学版, 2009, 28(2): 169-172.
WANG Guoqi, DENG Jun, ZHANG Xinhai, et al. Determination of parameters of injecting CO₂ to prevent spontaneous combustion in gob of fully mechanized top-coal caving[J]. Journal of Liaoning Technical University:Natural Science, 2009, 28(2): 169-172.
[14] 范喜生, 蔡昌宣, 张浪, 等. 采空区瓦斯浓度场数值模拟方法研究[C]. 2013年煤炭开采与安全国际学术研讨会论文集,2013: 226-231.
FAN Xisheng, CAI Changxuan, ZHANG Lang, et al. Study on the method of numerical modeling of gas concentration in goaf[C]. 2013 International Symposium on Coal Mining and Safety,2013:226-231.
[15] 刘宏波. 综放工作面采空区自然发火三维数值模拟研究[D]. 北京: 中国矿业大学 (北京), 2012.
LIU Hongbo. Study on three-dimensinal simulation of spontaneous combustion in goaf with fully mechanized caving face[D]. Beijing: China University of Mining and Technology(Beijing), 2012.

电厂烟道气预防遗煤自燃的合理含氧量模拟研究

Numerical simulation of reasonable oxygen content in flue gas for preventing residual coal spontaneous combustion

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	何文, 卢博凯, 石文芳, 祝思雨, 刘金朋. 超声空化效应对细粒尾矿的增渗作用[J]. 中国安全科学学报, 2024, 34(5): 91-100.
[2]	许娜, 梁燕翔, 王亮, 赵丽丽, 周雪晴, 张博. 基于知识图谱的煤矿建设安全领域知识管理研究[J]. 中国安全科学学报, 2024, 34(5): 28-35.
[3]	杨可明, 李婷婷, 马军, 李亚星, 江克贵, 赵项通. 基于最优PS点获取方法的矿山工业广场沉降监测[J]. 中国安全科学学报, 2024, 34(5): 44-51.
[4]	裴晓东, 姚志远, 王亮, 邵昊, 王凯, 吴征艳. 基于Unity3D的矿井火灾监测与防治虚拟仿真试验系统[J]. 中国安全科学学报, 2024, 34(3): 109-116.
[5]	徐永亮, 孙萌, 王兰云, 王云刚. 矿井带式输送机火灾烟流特性及其预警防控综述[J]. 中国安全科学学报, 2024, 34(3): 117-128.
[6]	李敏, 罗欧文, 鲁义, 施式亮, 李贺, 林志军. 再生顶板条件下煤自燃危险区域空间分布特征[J]. 中国安全科学学报, 2024, 34(3): 129-136.
[7]	吴芳华, 施式亮, 鲁义, 谷旺鑫, 谭嘉乐, 刘蔚廷. 磷石膏基自产气膨胀浆体防灭火性能研究[J]. 中国安全科学学报, 2024, 34(3): 148-154.
[8]	杜栋栋, 雷文杰, 李东会, 李哲. 矿井瓦斯抽采钻孔偏移特性研究[J]. 中国安全科学学报, 2024, 34(3): 155-161.
[9]	李懿, 陆伟, 李金亮, 陈云龙, 赵舒洁. 煤层注射成胶型抑尘剂影响因素及抑尘效果研究[J]. 中国安全科学学报, 2024, 34(3): 171-178.
[10]	于海淼, 徐泽鹏, 张硕, 祁慧. 煤矿工人职业健康研究进展的知识图谱分析[J]. 中国安全科学学报, 2024, 34(3): 230-236.
[11]	左明成, 焦文华. 面向煤矿井下作业场景的安全帽佩戴识别算法[J]. 中国安全科学学报, 2024, 34(3): 237-246.
[12]	张遵国, 袁新立, 陈毅, 唐朝, 马凯欣, 陈永强. 不同应力循环路径下砂岩的能量演化特征[J]. 中国安全科学学报, 2024, 34(2): 144-152.
[13]	游波, 崔大雄, 刘何清, 鲁义, 杨芯宇. 不同隔热材料下的深井巷道隔热降温模拟研究[J]. 中国安全科学学报, 2024, 34(2): 153-160.
[14]	王永军, 郑倩, 张河猛, 董伟, 张晓明, 佐佐木久郞. 采空区地下遗煤燃烧-地表碳通量相关性分析[J]. 中国安全科学学报, 2024, 34(2): 161-167.
[15]	郭鑫, 鲁义, 施式亮, 李贺, 李大芳. 高流态封孔注浆材料力学性能及水化机制[J]. 中国安全科学学报, 2024, 34(2): 168-175.